Thank you for selecting a FujiClean Wastewater Treatment System. Please read this installation
manual carefully before commencing installation.
TABLE OF CONTENTS
1. SAFETY PRECAUTIONS ................................................................................................ 1
2. SPECIFICATIONS OF THE SYSTEM ............................................................................. 2
3. INSTALLATION ............................................................................................................... 3
4. WIRING INSTRUCTIONS FOR ELECTRICIAN .............................................................. 7
5. COMMISSIONING ........................................................................................................... 9
6. WARRANTY & REPAIR POLICY .................................................................................. 10
1 SAFETY PRECAUTIONS
Read the safety precautions carefully before installing the FujiClean plant. The contents of this section are
important to ensure safety. Please pay special attention to the following symbols. Installation must be carried out in
accordance with the relevant safety regulations.
WARNING:
This symbol refers to a hazard or unsafe practice which can result in severe
personal injury or death.
CAUTION:
This symbol refers to a hazard or unsafe practice which can result in personal
injury and/or the potential for product or property damage.
WARNING
Electrical Safety
• All electrical work must be carried out by a licensed electrician.
Excavation Safety
• Before excavation work is carried out, the relevant person or principal contractor for construction work must:
o find out what underground services exist
o obtain relevant information about the service (location, type, depth, restrictions to be followed);
o record all relevant information
• All excavation work must be carried out in a safe manner in accordance with the relevant regulations.
Safe Lifting Procedures
• Lifting operation must be carried out in a safe manner in accordance with the relevant regulations.
CAUTION
Access Cover Openings
• Make sure the access covers are securely closed during the installation and operation.
Access Cover Lids
• Make sure there is no vehicular traffic load applied to the access cover lids during the installation and
operation. Do not stand on the access cover lids.
Green Riser Depth
• Maximum depth of cover (riser) is 500mm above the system. Mounting risers exceeding the 500mm height
onto the system would void the warranty.
Above Ground & Half Buried Ground Install
• FujiClean ACE is designed to be installed below ground, as per this installation manual.
•
Do not install this system above ground or half buried above ground without consulting Fuji
Clean Australia for installation instruction.
To Next Page
Loading...
