Goes Cobalt - Hauling Cargo

157 pages

Save Page as PDF

To Next Page

To Previous Page

-64-

Weight distribution in the rear rack should be as far forward and as low as possible. Carrying

a high load

Main Page

Introduction5
Table of Contents6
VIN Engine Serial no7
Safety9
Age Restrictions9
Know Your Vehicle9
Safety Training9
Operation Safety18
Driver Safety27
Safety Decals and Locations38
Features and Controls44
Electrical Switches44
Light Switch44
Turn Switch45
Horn Switch Button45
Engine Start Switch45
Hazard Switch45
Brake46
Brake Fluid47
Parking Brake49
Important Safeguards49
Fuel Tank50
Fuel Safety51
Belt Lifetime Span51
On-Command Four-Wheel Drive Switch52
Throttle Lever54
Speed Limit Bolt55
Main Switch Functions56
Indicator and Warning Lights57
Safety Belt Indicator57
Turning Indicators57
High Beam Indicator58
EPS Indicator58
Engine Oil Pressure58
Neutral Indicator58
Dashboard59
Gear Indications59
Mileage Display60
Coolant Temperature Gauge60
Dashboard Setting/Adjustment List61
Break-In Period62
Pre-Ride Inspection63
Starting the Engine65
Starting a Cold Engine65
Gear Selector Operation and Reverse Driving67
Shifting H to L67
Shifting L to H68
Neutral to Reverse68
Hauling Cargo70
Load Distribution72
Driving Safely73
Driving Procedures73
Making Turns74
Driving on Slippery Surfaces75
Driving Uphill76
Side Hilling77
Driving down Hill78
Turning Around on a Hill79
Driving through Water80
Driving in Reverse83
Parking on an Incline84
Turning ATV85
Maintenance and Lubrication87
Severe Use Definition87
Maintenance Chart Key87
Periodic Maintenance Chart88
Lubrication Recommendations93
Lubrication Chart Key93
Engine Oil94
Engine Oil Check94
Change Engine Oil96
Rear Gear Case Oil97
Rear Gear Case Oil Replacement97
Front Gear Case Oil Measurement98
Cooling System100
Change Coolant101
Changing the Coolant102
Axle Boots104
Spark Plug Inspection104
Spark Plug Specification105
Air Filter Element Cleaning106
Spark Plug Torque106
Maintenance & Lubrication107
Cleaning Spark Arrester108
Drain Bolt Right Cover110
Engine Idle Speed Adjustment111
Throttle Cleaning and Adjustment111
Adjusting Throttle Lever112
Front Brake Disc Inspection112
Rear Brake Disc Inspection113
Check Brake Liquid Level113
Check Brake Fluid Level114
Process to Replace Brake Fluid115
Rear Brake Lever Free-Play Adjustment116
Rear Brake Pedal Adjustment116
Rear Brake Light Switch117
Cable Inspection and Lubrication117
Rear Knockle Upper and Lower Pivot Lubrication117
Rear Brake Switch Adjsutment118
Wheel Removal119
Wheel Installation119
Antidote120
Battery Maintenance121
Fuse Replacement121
Replacement of Headlight Bulb122
Headlight Beam Adjustment123
Tail Light/Brake Light Replacement123
Front and Rear Suspension Adjustment124
Installation Instructions125
Coupling Device Installation125
Combinations of the Trailer's Articulation126
Clean & Storage126
Cleaning the ATV126
Washing the ATV127
Waxing the ATV127
Vehicle Immersion128
Cleaning of ATV129
Cleathe Extereior130
Stabilize the Fuel130
Engine Oil and Oil Filter131
Air Filter/Air Box131
Fluids Levels131
Lubricate the Engine132
Lubricate133
Battery Storage133
Engine Anti-Freeze133
Storage Area/Covers133
Transporting the Atv/Quadricycle134
Chrome Wheel Care134
Removing Corrosion135
Troubleshooting136
Drive Belt and Cover Problems136
Engine Doesn't Turn over138
Engine Turns Over, Fails to Start139
Engine Pings or Knocks139
Engine Backfires140
Engine Runs Irregularly, Stalls or Misfires140
Pcode List144
PCODE Uses 4 Digit Flashing：144
EPS Fault Code Table147
EPS Fault Diagnosis and Solution149
Specifications150
Electricity Diagram156

Goes Cobalt - Hauling Cargo

Table of Contents

Related product manuals