GREAT PLANES Revolver .61 - User Manual

Champaign, Illinois
(217) 398-8970, Ext 5
airsupport@greatplanes.com
Entire Contents © Copyright 2009 GPMA1019 Mnl
READ THROUGH THIS MANUAL BEFORE STARTING CONSTRUCTION. IT CONTAINS IMPORTANT
INSTRUCTIONS AND WARNINGS CONCERNING THE ASSEMBLY AND USE OF THIS MODEL.
WARRANTY
Great Planes
®
Model Manufacturing Co. guarantees this kit to
be free from defects in both material and workmanship at the
date of purchase. This warranty does not cover any component
parts damaged by use or modification. In no case shall Great
Planes’ liability exceed the original cost of the purchased kit.
Further, Great Planes reserves the right to change or modify this
warranty without notice.
In that Great Planes has no control over the final assembly or
material used for final assembly, no liability shall be assumed nor
accepted for any damage resulting from the use by the user of
the final user-assembled product. By the act of using the
user-assembled product, the user accepts all resulting liability.
If the buyer is not prepared to accept the liability associated
with the use of this product, the buyer is advised to return
this kit immediately in new and unused condition to the
place of purchase.
To make a warranty claim send the defective part or item to
Hobby Services at the address below:
Hobby Services
3002 N. Apollo Dr. Suite 1
Champaign IL 61822 USA
Include a letter stating your name, return shipping address, as
much contact information as possible (daytime telephone
number, fax number, e-mail address), a detailed description of
the problem and a photocopy of the purchase receipt. Upon
receipt of the package the problem will be evaluated as quickly
as possible.
Radio: 4-channel minimum with
4-5 servos and standard
size receiver
Motor: RimFire
™
80 (50-55-500)
outrunner brushless motor
Engine: .61 –.75 [10– 12.5 cc] two stroke
.81–.91 [13.5–15 cc] four stroke
Wingspan:
70 in
[1780mm]
Wing Area: 832 in
2
[53.7 dm
2
]
Weight:
8.5 – 9.25 lb
[3850–4190 g]
Wing
Loading:
24– 26 oz/ft
2
[73–79 g/dm
2
]
SPECIFICATIONS
INSTRUCTION
MANUAL

Summary

Model Component Selection

Radio Equipment

Details on the minimum 4-channel radio system and servos required for the Revolver 61 ARF.

Power System Recommendations

Recommended engine/motor sizes, ESC, battery, and propeller for the Revolver 61 ARF.

Batteries and Charger

Specifications for LiPo battery packs, series connectors, and recommended chargers.

Additional Items Required

List of hardware, adhesives, and building supplies needed to complete the Revolver 61 ARF.

Building Preparations and Parts

Optional Supplies and Tools

List of optional tools that can assist in building the Revolver ARF.

Important Building Notes

Key considerations and tips for successful assembly, including fitting and glue usage.

Ordering Replacement Parts

Information on how to order replacement parts for the Revolver 61 ARF.

Kit Inspection and Contents

Guidance on inspecting kit parts for quality and identifying components in the kit.

Aircraft Construction Steps

Build the Wing

Instructions for installing aileron servos and pushrods into the wing panels.

Build the Fuselage

Steps for assembling the tail section, installing servos, and mounting the landing gear.

Install the Power System

Guidance for installing glow engines or brushless motors, including fuel tank setup.

Finish the Model

Steps for installing the receiver, cowl, canopy, pilot, and applying decals.

Pre-Flight Procedures and Safety

Preparing the Model for Flight

Steps to install batteries, check controls, set throws, and balance the model.

Preflight Inspections and Checks

Covers identifying the model, charging batteries, balancing props, and ground checks.

Safety Guidelines and Codes

Details on engine safety, lithium battery care, AMA safety code, and safe flying practices.

Flying and Operation

Checklist and Fuel Mixture

Final pre-flight checklist and advice on adjusting fuel mixture for optimal engine performance.

Flying Techniques

Guidance on takeoff, flight maneuvers, and landing the Revolver aircraft.

GREAT PLANES Revolver .61 Specifications