Gree VIR18HP230V1B - 8.5 Installation of Indoor Unit; Install Wall-mounting Frame; Connect Indoor Unit Pipes

36
Installation and Maintenance
Service Manual
Outlet
pipe
Drain hose
Drain hose
Ta
p
e
Outlet pipe
Insulating pipe
Torque wrench
Open-end
wrench
Indoor pipe
Pipe
Union nut
Union nutPipe joint
Pipe
5HIHUWRWKHIROORZLQJWDEOHIRUZUHQFKPRPHQWRIIRUFH
:
Left
Rear left
Right
Rear right
Cut off
the hole
Left Right
Drain hose
Insulating pipe
5-10 °
2 1/6 or
(2 3/4)inch
Indoor
Outdoor
3D\ DWWHQWLRQWRGXVWSUHYHQWLRQDQGWDNHUHOHYDQWVDIHW\
PHDVXUHVZKHQRSHQLQJWKHKROH
7KHSODVWLFH[SDQVLRQSDUWLFOHVDUHQRWSURYLGHGDQGVKRXOG
EHERXJKWORFDOO\
$GGLQVXODWLQJSLSHLQWKHLQGRRUGUDLQKRVHLQRUGHUWR
SUHYHQWFRQGHQVDWLRQ
7KHSODVWLFH[SDQVLRQSDUWLFOHVDUHQRWSURYLGHG
$VVKRZLQ)LJ
)LJ
)LJ
)LJ )LJ
)LJ
)LJ
)LJ
)LJ
)LJ
)LJ
LQWKHKROHV
)L[WKHZDOOPRXQWLQJIUDPHRQWKHZDOOZLWKWDSSLQJVFUHZV
67;7$DQGWKHQFKHFNLIWKHIUDPHLV¿UPO\LQVWDOOHGE\
SXOOLQJWKH IUDPH,IWKHSODVWLFH[SDQVLRQSDUWLFOHLVORRVH
SOHDVHGULOODQRWKHU¿[LQJKROHQHDUE\
3. Install Wall-mounting Frame
&KRRVHWKHSRVLWLRQRISLSLQJKROHDFFRUGLQJWRWKHGLUHFWLRQ
RIRXWOHW SLSH7KHSRVLWLRQRISLSLQJKROHVKRXOGEHDOLWWOH
ORZHUWKDQWKHZDOOPRXQWHGIUDPH$VVKRZLQ)LJ
5. Connect the Pipe of Indoor Unit
$LPWKHSLSHMRLQWDWWKHFRUUHVSRQGLQJEHOOPRXWK$VVKRZ
LQ)LJ
3UHWLJKWHQLQJWKHXQLRQQXWZLWKKDQG
$GMXVWWKHWRUTXHIRUFHE\UHIHUULQJWRWKH IROORZLQJVKHHW
3ODFHWKHRSHQHQGZUHQFKRQWKHSLSHMRLQWDQGSODFHWKH
WRUTXHZUHQFK RQWKHXQLRQQXW7LJKWHQWKHXQLRQQXWZLWK
WRUTXHZUHQFK$VVKRZLQ)LJ
:UDSWKHLQGRRUSLSHDQGMRLQWRIFRQQHFWLRQSLSHZLWK
LQVXODWLQJSLSHDQGWKHQZUDSLWZLWKWDSH$VVKRZLQ)LJ
6. Install Drain Hose
&RQQHFWWKHGUDLQKRVHWRWKHRXWOHWSLSHRILQGRRUXQLW$V
VKRZLQ)LJ
%LQGWKHMRLQWZLWKWDSH$VVKRZLQ)LJ
4. Outlet Pipe
7KHSLSHFDQEHOHGRXWLQWKHGLUHFWLRQRIULJKWUHDUULJKW
OHIWRUUHDUOHIW$VVKRZLQ)LJ
:KHQVHOHFWLQJOHDGLQJRXWWKHSLSHIURPOHIWRUULJKWSOHDVH
FXWRIIWKHFRUUHVSRQGLQJKROHRQWKHERWWRPFDVH$VVKRZLQ
)LJ
2SHQDSLSLQJKROHZLWKWKHGLDPHWHURI  LQFK
RQWKHVHOHFWHGRXWOHWSLSHSRVLWLRQ,QRUGHUWRGUDLQVPRRWKO\
VODQWWKHSLSLQJKROHRQWKHZDOOVOLJKWO\GRZQZDUGWRWKH
RXWGRRUVLGHZLWKWKHJUDGLHQWRI$VVKRZLQ)LJ
Note:
Note:
+H[QXWGLDPHWHULQFK 7LJKWHQLQJWRUTXHIW·Ibf)
ĭ 11.10~14.75
ĭ 22.82~29.50
ĭ 33.19~40.56
ĭ 44.24~47.94
ĭ 51.32~55.31
Left
Wall
Φ2 1/6(2 3/4) Φ2 1/6(2 3/4)
Right
Mark in the middle of it
Level meter
Rear piping hole
Wall
Space
to the
wall
above
6inch
Space
to the
wall
above
6inch
Rear piping hole