What to do if my Hagie STS10 Paint Sprayer will not move in either direction?
If your Hagie Paint Sprayer will not move in either direction: * Set the engine at operating RPM. * Fill the hydraulic reservoir to the proper level with approved oil. * Replace the pressure filter.
How to fix a Hagie STS10 engine that will not crank?
If the engine of your Hagie Paint Sprayer will not crank, try the following: * Recharge or replace the battery. * Clean and tighten the connections. * Test, rebuild, or replace the starter. * Check or replace the fuse. * Turn the Battery Disconnect Switch to the ON position. * Engage the parking brake.
What to do if my Hagie Paint Sprayer engine overheats?
If your Hagie Paint Sprayer engine overheats, consider these solutions: * Reduce the load. * Remove any foreign material and clean all items. * Replace the radiator cap. * Check the fan speed. * Replace the thermostat. * Refill the coolant to the proper level with the recommended coolant.
Why is the entire electrical system dead on my Hagie STS10?
If the entire electrical system of your Hagie Paint Sprayer is dead, try these steps: * Replace the battery. * Clean and tighten the battery connections. * Tighten the alternator belt. * Replace the alternator. * Turn the Battery Disconnect Switch to the ON position.
What causes a Hagie STS10 engine to misfire?
If your Hagie Paint Sprayer engine misfires, runs unevenly, or has low power, try these solutions: * Drain, flush, replace the filter, and fill the system. * Replace the air cleaner element. * Drain the system and change to a higher fuel grade. * Open the fuel tank vent (in cap). * Replace the fuel filter(s).
Why is the solution pump not producing adequate pressure in my Hagie Paint Sprayer?
If the solution pump on your Hagie Paint Sprayer is not producing adequate pressure: * Remove the screen, clean it thoroughly, and tighten the strainer cap to avoid air leaks. * Inspect and tighten all fittings on the suction line. * Ensure the Main Tank Valve is completely open. * Check for any obstruction at the inlet end of the hose that may be causing high vacuum on the hose.
What if AWS System is ON, but rear tires do not follow behind the front tires on my Hagie Paint Sprayer?
If the AWS System is ON, but the rear tires do not follow behind the front tires on your Hagie Paint Sprayer, this is left up to the operator’s discretion.
Why is the hydraulic pump noisy on my Hagie STS10?
If your Hagie Paint Sprayer's hydraulic pump is noisy, ensure that you: * Fill the hydraulic reservoir to the proper level with approved oil.
What to do if the electric solution valve malfunctions on my Hagie STS10 Paint Sprayer?
If your Hagie Paint Sprayer's electric solution valve malfunctions, you can try: * Cleaning and tightening the ground. * Cleaning the contact terminals. * Checking the continuity and replacing the wire. * Replacing the switch. * Replacing the valve.
Why is the hydrostatic system noisy on my Hagie Paint Sprayer?
If the hydrostatic system on your Hagie Paint Sprayer is noisy: * Allow an adequate warm-up period. * Increase the engine speed. * Fill the hydraulic reservoir to the proper level with approved oil.
Contact local John Deere dealer for service and assistance.
Contact local John Deere dealer for further information on product warranty.
Machine identification by frame serial number, engine, pump, and component serial numbers.
Detailed dimensions and specifications for different boom sizes and configurations.
Defines the sprayer's design for chemical and fertilizer application to field crops; misuse is prohibited.
General safety guidelines, including starting procedures and driving cautions.
Emphasizes the importance of wearing the seat belt at all times during operation.
Details the cab's ROPS for operator protection and inspection guidelines for integrity.
Describes adjustments for the operator's seat, including armrest, recline, and slide features.
Covers the front console and steering column controls for operating the machine.
Explains the central control center for machine functions, settings, and diagnostics.
Explains the AWS system, its operation modes, and recommendations for best practices.
Provides a pre-operational checklist and cold start procedure for the engine.
Information on the Tier 4 Final Aftertreatment System, DEF requirements, and warnings.
Explains the hydrostatic drive system components and operation for machine movement.
Covers AWS terminology, components, operating modes, and recommendations.
Lists and describes key hydraulic system components, including pumps and filters.
Details the operation and safety precautions for the reversible fan system.
Instructions for adjusting hydraulic tread width for optimal application and crop clearance.
Explains how to lower and raise the machine's ladder safely.
Information on battery access, safety precautions, and charging procedures.
Explains the function and operation of the battery disconnect switch.
Lists fuse and relay locations and their corresponding functions for interior and exterior circuits.
Describes connections for video cameras, including the rear camera and auxiliary inputs.
Explains the electro-hydraulic control system for 90/100' spray booms.
Critical safety precautions for operating near power lines, including warning messages.
Lists and describes all components of the solution delivery system.
Comprehensive guide on operating the solution system, including getting started and filling/draining.
Procedures for checking and maintaining hydraulic oil, wheel hub oil, and engine oil levels.
Procedures for checking engine oil level, capacity, type, and change intervals.
Information on DEF, its function, tank capacity, type, storage, and indicator lamps.
Procedures for servicing and replacing engine air intake filters, pre-cleaners, and radiator screens.
Safety precautions and procedures for transporting the sprayer on roadways or trailers.
Instructions and safety warnings for lifting the machine using bottle jacks.
Procedures for connecting and disconnecting spray booms using the quick-tach system.
Common problems, their possible causes, and suggested remedies for engine, pump, and system issues.
General| Brand | Hagie |
|---|---|
| Model | STS10 |
| Category | Paint Sprayer |
| Language | English |
To Next Page
