HAMPTON BAY 1002 938 103

To Next Page

THANK YOU

continually create quality products designed to enhance your home. Visit us online to see our full line of products available for your home

improvement needs. Thank you for choosing Hampton Bay!

Cross Ridge Gas Fire Pit Table

1-855-HD-HAMPTON

HAMPTONBAY.COM

DANGER

· FLAMMABLE GAS UNDER PRESSURE.

LEAKING LP-GAS MAY CAUSE A FIRE OR EXPLOSION IF IGNITED

CAUSING SERIOUS BODILY INJURY OR DEATH.

CONTACT LP GAS SUPPLIER FOR REPAIRS, OR DISPOSAL OF THIS

CYLINDER OR UNUSED LP-GAS.

WARNING

FOR OUTDOOR USE ONlY.*

DO NOT USE OR STORE CYLINDER IN A BUILDING,

GARGE OR ENCLOSED AREA.

WARNING:

Know the odor of LP-gas. If you hear, see or smell

leaking LP-gas, immediately get everyone away

from the cylinder and call the Fire Department.

Do not attempt repairs.

Caution your LP-gas supplier to:

Be certain cylinder is purged of trapped air prior

LP-gas is heavier than air and may settle in low places

when dissipating.

Contact with the liquid contents of cylinder will cause

freeze burns to the skin.

Do not allow children to tamper or play with cylinder.

When not connected for use, keep cylinder valve turned

off. Self contained appliances shall be limited to a

cylinder of 30 lb capacity or less.

Do not use, store or transport cylinder where it would

be exposed to high temperatures. Relief valve may open

When transporting, keep cylinder secured in an upright

position which cylinder valve turned off.

DO NOT REMOVE, DEFACE, OR OBLITERATE THIS LABEL

*EXCEPT AS AUTHORIZED BY ANSI/NFPA 58.

DANGER. Do not store a spare LP cylinder under or near a barbecue grill, or other

serious injury may occour.

WHEN CONNECTING FOR USE:

Use only in compliance with applicable codes.

Read and follow manufacturer’s instructions.

Consult manufacturer’s instructions

concerning the cylinder connection provided

with your appliance.

Be sure regulator vent is not pointing up.

Turn off all valves on the appliance.

Do not check for gas leaks with a match or

Apply soapy water at areas marked

”X”. Open cylinder valve. If bubble appears,

close valve and have LP-gas service person

make needed repairs. Also, check appliance

valves and connections to make sure they

do not leak before lighting appliance.

Light appliance(s) following manufacturer’s

instructions.

When appliance is not in use, keep the

cylinder valve closed.

Cylinder

Pressure relief valve

Cylinder valve hand wheel

Point of connection

Liquid level indicator

(optional)

Item #1002 938 103

Model #G-FTB-51057B

USE AND CARE GUIDE

Questions, problems, missing parts? Before returning to the store,

call Hampton Bay Customer Service

8 a.m. - 7 p.m., EST, Monday – Friday, 9 a.m. – 6 p.m., EST, Saturday

Main Page

Need help?

Do you have a question about the HAMPTON BAY 1002 938 103 and is the answer not in the manual?

Summary

Assembly

Assembling the Legs

Step-by-step instructions for attaching the legs to the main unit.

Assembling the Side Panels

Step-by-step instructions for attaching the side panels.

Assembly (continued)

Assembling Side Panel with Window

Step-by-step instructions for attaching the side panel featuring a window.

Assembling the Door

Step-by-step instructions for attaching the door to the unit.

Assembling the Cylinder

Instructions for placing and securing the propane cylinder.

Assembling the Gas Tank Support

Step-by-step instructions for installing the support for the gas tank.

Operation

Initial Lighting Procedures

Guidance for first-time use, including initial odor management.

Summary

Assembly

Assembling the Legs

Step-by-step instructions for attaching the legs to the main unit.

Assembling the Side Panels

Step-by-step instructions for attaching the side panels.

Assembly (continued)

Assembling Side Panel with Window

Step-by-step instructions for attaching the side panel featuring a window.

Assembling the Door

Step-by-step instructions for attaching the door to the unit.

Assembling the Cylinder

Instructions for placing and securing the propane cylinder.

Assembling the Gas Tank Support

Step-by-step instructions for installing the support for the gas tank.

Operation

Initial Lighting Procedures

Guidance for first-time use, including initial odor management.

This document is a Use and Care Guide for the Hampton Bay Cross Ridge Gas Fire Pit Table, Model #G-FTB-51057B, Item #1002 938 103. It provides comprehensive instructions for assembly, operation, maintenance, and troubleshooting, along with important safety information.

Function Description:

The Hampton Bay Cross Ridge Gas Fire Pit Table is an outdoor appliance designed to provide warmth and ambiance using propane gas. It features a burner integrated into a tabletop, surrounded by lava rock, and includes a lid for covering the fire bowl when not in use. The unit is designed for use with a standard 20 lb. propane cylinder, which is stored within the table's enclosure. An electronic igniter facilitates lighting the burner, and a control knob allows for adjusting the flame height. The appliance is intended for outdoor use only and should not be used for preparing food.

Important Technical Specifications:

Model Number: G-FTB-51057B
Item Number: 1002 938 103
Fuel Type: Propane gas
Propane Cylinder: Standard 20 lb. propane cylinder (sold separately), not to be filled beyond 80% full.
Gas Supply Pressure: 25 PSI to 250 PSI
Max. Gas Supply: 6791.3 in wc (1725 kPa)
Manifold Pressure: 11 in wc (2.74 kPa)
Ignition: Electronic igniter (requires 1 AAA battery)
Safety Features: Thermocouple safety, overfill protection device (OPD) for the LP-gas supply cylinder, heat shield to prevent contact with the fire bowl when adjusting the propane valve.
Construction: Metal frame with a 1-year limited warranty against manufacturing defects.
Dimensions (from package contents): Includes a lid, lava rock (11 lbs), tabletop with burner, side panels, legs, door, and gas tank support.

Usage Features:

Outdoor Use Only: Explicitly stated for safety, prohibiting use in buildings, garages, or enclosed areas.
Easy Assembly: The manual provides step-by-step instructions for assembling the legs, side panels, gas tank support, and door. Tools required include a Phillips screwdriver (not included) and an M6 wrench (included).
Propane Cylinder Integration: The design allows the propane cylinder to be stored securely within the table's structure, hidden by a door.
Electronic Ignition: A push-button electronic igniter simplifies starting the fire. If the electronic igniter fails, a long match or butane lighter can be used.
Adjustable Flame: A control knob allows users to adjust the flame height from low to high.
Lava Rock: Lava rock is placed in the fire bowl to enhance the aesthetic and distribute heat. It should not cover the ignition portion of the burner.
Lid for Fire Bowl: A lid is provided to cover the fire bowl when not in use, protecting the lava rock and burner. The lid must be removed during operation and can be hung on the side panel.
Safety Warnings: Numerous warnings are provided throughout the manual, covering topics such as flammable gas, fire/explosion hazards, carbon monoxide hazard, high surface temperatures, and proper connection procedures. Users are advised to know the odor of LP-gas and to contact emergency services if a leak is suspected.
Wind Conditions: The unit may shut down if winds exceed 10 mph (16 km/h).
Storage: Instructions for storing the unit between uses and during extended inactivity, emphasizing disconnecting the LP source and storing in a well-ventilated, sheltered area.

Maintenance Features:

Regular Cleaning: Users are advised to keep the exterior surface clean using warm soapy water and to keep the area around the burner dry. Flammable or corrosive cleaning agents should not be used.
Annual Inspection: The appliance should be inspected at least annually by a qualified service person for damaged parts (hoses, regulators, pilots, burners) and for the presence of spiders, spider webs, or other insects.
Burner Maintenance: The burner holes should be cleaned with a heavy-duty pipe cleaner, and compressed air can be used for smaller particles. The burner should be inspected annually for cracks, insect nests, or excessive corrosion. A damaged burner must be replaced with a manufacturer-specified part.
Clear Airflow: It is imperative to keep the control compartment, burners, and circulating air passageways clean and free from combustible materials, gasoline, and other flammable vapors and liquids. The ventilation opening(s) of the cylinder enclosure must be kept free and clear from debris.
Leak Testing: A leak test must be performed annually, before initial use, and whenever gas components are replaced or serviced. This involves applying a soapy water solution to connections; bubbles indicate a leak. Open flames must never be used to check for leaks.
Thermocouple and Regulator: Instructions are provided for cleaning or replacing the thermocouple and checking the regulator if issues arise.
Carbon Deposits: Carbon deposits can create a fire hazard and should be cleaned from the reflector, thermocouple, and emitter screen with a dry cloth.