Heat&Glo PRIMO-II-48 - User Manual

1
Heat & Glo • PRIMO-II Owner’s Manual • 2670-981 Rev. D • 7/23
Owner’s Manual
Operation and Maintenance
CAUTION! Risk of Fire! DO NOT store instruction manuals inside replace cavity.
High temperatures could cause a re.
INSTALLER: Leave this manual with the appliance, not inside the appliance.
CONSUMER: Retain this manual for future reference. Do not store inside the appliance.
Contact your dealer with questions regarding installation, operation or service.
NOTICE: DO NOT discard this manual!
This appliance may be installed as an OEM
installation in manufactured home (USA
only) or mobile home and must be installed
in accordance with the manufacturer’s
instructions and the Manufactured Home
Construction and Safety Standard, Title 24
CFR, Part 3280 in the United States, or the
Standard for Installation in Mobile Homes,
CAN/CSA Z240 MH Series, in Canada.
This appliance is only for use with the type(s)
of gas indicated on the rating plate. This
appliance is not convertible for use with other
gases, unless a certied kit is used.
• DO NOT store or use gasoline or other am-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Leave the building immediately.
- Immediately call your gas supplier from
a neighbor’s phone. Follow the gas sup-
plier’s instructions.
- If you cannot reach your gas supplier, call
the re department.
• Installation and service must be performed
by a qualied installer, service agency, or the
gas supplier.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
Models:
PRIMO-II-48
PRIMO-II-48ST
PRIMO-II-60
PRIMO-II-60ST
PRIMO-II-72
PRIMO-II-72ST
DANGER
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A (glass) barrier designed to reduce the risk of
burns from the hot viewing glass is provided
with this appliance and must be installed for
the protection of children and other at-risk
individuals.
SafeSurface
TM
barrier glass must be ordered separately
at time of appliance purchase. See Section 12.B of ap-
pliance Installation Manual.

Summary

1 Welcome

A. Congratulations

Congratulates the owner on selecting the fireplace.

Local Dealer Information

Section for recording local dealer and appliance details.

B. Limited Lifetime Warranty

2 Product Specific Information

A. Appliance Certification

Lists appliance certifications and standards for safety and performance.

B. Glass Specifications

Details tempered glass specifications and safety compliance.

C. BTU Specifications

Provides BTU input and output specifications for various models.

D. Electronic Control Module Compliance

Outlines FCC and IC compliance for the electronic control module.

3 Important Safety and Operating Information

A. Appliance Safety

Crucial safety guidelines for operating the appliance safely.

Clear Space

Specifies required clearance around the appliance to prevent fire hazards.

B. General Operating Parts

Identifies and illustrates the main operating components of the appliance.

C. Fuel Specifications

Details compatible fuel types and conversion requirements for operation.

D. Wall and Mantel Temperatures

Explains safe temperature limits for surfaces around the fireplace.

E. Good Faith Wall Surface;TV Guidelines

Provides recommendations for installing TVs above the appliance.

F. Lighting Instructions (IPI)

Step-by-step guide for safely lighting the appliance using IPI.

G. Appliance Break-In

Procedure for initial operation to cure materials and remove odors.

H. Heat Management

Discusses burn rate control and optional heat distribution systems.

I. Detailed Component Operating Instructions

Explains the operation of specific components like the ECM and remote controls.

4 Maintenance and Service

A. Maintenance: Frequency and Tasks

Outlines a schedule for regular maintenance tasks and responsibilities.

B. Maintenance Tasks - Homeowner

Lists maintenance tasks that can be performed by the appliance owner.

C. Maintenance Tasks - Qualified Service Technician

Details maintenance tasks that require a professional service technician.

5 Frequently Asked Questions and Troubleshooting

A. Frequently Asked Questions - Appliance

Addresses common appliance operational issues and provides solutions.

B. Frequently Asked Questions - IntelliFire Touch Controls (IFT2-RC450)

Answers common questions related to the IntelliFire Touch remote control system.

C. Troubleshooting - IntelliFire Touch 2.0 Ignition System

Guides users through troubleshooting ignition system errors and codes.

D. Troubleshooting - Appliance

Provides solutions for general appliance operational problems and lockouts.

6 Reference Materials

A. Accessories

Lists optional accessories available for purchase and installation.

B. Service Parts

Catalog of replacement parts with part numbers and diagrams for various models.

C. Contact Information

Provides company contact details and website for support.

Heat&Glo PRIMO-II-48 Specifications