Hobie 3.5 - Page 5

2.1 ..0-.t•. irTLA :J•> . f'
:--= .9-....p'.: 1 --3*i:*.1
.1! i.li
--I-/•2-*.•-i
- IL - 1. I-- .-I .--Prf.•.%.•
.. 7.0 ) "-.ZTA
p. .6 · 4... 1.rE- -,t--.· --SKE- I
&41"ll'I•
-/.-/................--'.......
.....4 ' ....»,4. I ........
'S/Blwpir=L.a
3=9- %2419*172%931
r: Ar, r#/1-....2 /\
0-r-:li•":--•001,4
-fre. 1.- 036- -«*-
"
1 -
-
1 -·u ·.6. ·4.ZL-'
---
,•·••W· i;J.•2.-- /=2.-
-S--C#•ki...LE::·.· .-...
•--,96&...... ilillill.*'llfi --z--.6,
1 - f.- -9.%5.'£7-'00.... -3 .5/8
1.'-f-' .r-: . .3/. - ... p, I. - -- ./
.. 3=«.ir.(55
-
119
:...4 --
r.,....: -/*I'.....-036J. ..,»-+.L--L.A,'i-i:-•
12
Assemble the wing section noting that the Coat the corner pylons with a generous amount
grooves in the side bars are in the front facing of white grease or vaseline. Carefully place and
inside, and chain plates are on outside. balance the wing section on top of the four
corner pylons ( an assistant is most helpful ).
., -·------=4 ------·--,-........: Ger-f.-,r.•
IM//I.*..I-, I #.AA.. ,--IZ,042*•...4 R-I......I
h - 1 1, /Ff<-
45
Repeat the same procedure on the right front, Beginning again at the front left casting, rub-
left rear and right rear castings. ber mallet the casting all the way down until
the holes line up.
CAUTION: Strike the casting on the flat por-
tion directly over the pylon only.
3
Beginning at the front left, line up the corner
casting with pylon by using a rubber mallet
and gently tapping forward and side edges.
Once it is lined up, tap the casting down only
part way on the pylon.
ill«
•i, /
I .10.
1.2
f'
j...> 036 '.
1,» 4-• 231-11 .»
AAL :.btl...• 'V, 24*
9+12;:4....841 \•.
6
Install (21) Pylon Nuts and Bolts and tighten
securely.
HIP•-1......
«* -*=r •n r« -: 1-,-
&,0rity: -, i.:: 1:-3=4 '.11,1. 1 : B:,624..J>_» I..: '. 1-:.i--.,il ;. i
E"-4,·4,/FL:6-L: .*;;,*1·r,·tall.'64 .r<4'c-f, ...f
w•.f:.ssz,· is:,12;,036, - 2. . 1 »JS •3256F•#521&0•1 . ."24 L•K,%11•1 •-2--* 1.*b••
•••,•- •R--»1-$5 .-...1. 29/mi- 7 i. llililliir
=Mal.=1 -*-<416'L-, 6•--=··s=15*l/T,V&•<5: •.4
lf#.:.:l c.. .i =*l W- -
ILL.. _·.. -.:Fr•.32.-T'.1 .1 *:imi- I 4,/.5,45:1.2.' --9..7....-7..1 lestekiacuze:.Frifi•fiL:.i.. - : . '-I /
-•I•"lar....•--5.22%/_. &* 2 ·. . ...":201;/Ir.:LEE.fire.&-..li•jili F...1.- r.:6//41;Efi: 1.1 .Silit.clillillilfiu
m.'2-4,-036. -
7
Lay both trampoline halves over the front
cross·bar noting that the grommets run down
the center and along the rear.
Insert the trampoline into the groove on the
forward inside of the side bars. Gradually feed
them back all the way to the rear. Next, insert
the front of the trampoline into corner slot in
the front crossbar and feed them all the way to
the center.
Insert the Rear Trampoline Slide into the Rear
Crossbar.
8
9
5
46.r -1
\
>L-ILE..
iff-*254
*fA-