Homelite HG1800 - User Manual

(a) With generator running, power is now
provided to the receptacles.
(b) Plug in items to be powered, using only
grounded extension cords.
(c) The included 12V DC Charging Cable plugs
directly into the 12 Volt receptacle (see
Figure 3).
WARNING: DO NOT overload generator or electrical cords.
(a) Turn fuel valve to the ON
position (see Figure 2).
(b) Move choke control lever fully
to the right (see Figure 2).
(c) Select the ON position on the
engine ON/OFF switch (see
Figure 2).
(d) Start generator by slowly
pulling on the starter rope
handle (see Figure 2) until
resistance is felt. Then pull
cord rapidly to overcome
compression to start engine.
(e) Slowly move choke control
lever fully to the left as engine warms.
Quick Start Guide
1800 Watt Portable Generator
ITEMS NEEDED:
Utility Knife
Oil Funnel
Unleaded Fuel
ITEMS INCLUDED:
Operator Manual (not shown)
(a) Generator
(b) 12V DC Charging Cable
a
b
1
2
3
4
5
6
(a) Remove inner packaging.
(b) Lift unit out of carton.
Prior to use, check to ensure that you have all the included items. If items are
missing or damaged call 1-800-242-4672.
UNPACK GENERATOR
ADD FUEL AND CHECK ENGINE
LUBRICANT
(a)Movegeneratoroutsidetoaat,level
surface.
(b)Removelubricantllcap.Engine ships
without lubricant. Use a funnel to add
18 oz. 4-cycle small engine lubricant
10W30 into the engine. Fill to the upper
mark of the oil dipstick. Use caution to avoid
spilling.
(c)Removefuelcap(seeFigure1)andllwithREGULAR UNLEADED fuel.
Donotoverll.
Keep maximum fuel level 1/4 inch below the top of the fuel tank.
(d) Replace fuel cap.
(a)Movegeneratoroutsidetoaat,levelsurface,awayfromdoors,windows
and vents.
Figure 2
Figure 3
START GENERATOR
POWER CONTROL PANEL
(a) Before shutting engine off, unplug all electrical loads.
(b) Let engine run for 2 minutes.
(c) Turn engine ON/OFF to OFF (see Figure 2).
(d) Turn fuel valve to OFF (see Figure 2).
(e) If generator is to be stored for longer than 30 days, refer to the operator’s
manual for further instructions.
SHUT DOWN AND STORAGE PROCEDURES
987000-358
5-28-08 (REV:03)
Manual Starter Rope Fuel Valve ON/OFF
Engine Choke Engine ON/OFF
CAL
L
1-800-242-4672
www
.homeli
te.com
Typical Generator Shown
Exhaust Port
Pointed away from
dwelling openings
DANGER DANGER PELIGRO
Using a generator indoors CAN KILL YOU IN MINUTES.Generator exhaust contains carbon monoxide. This
is a poison you cannot see or smell.
L’utilisation d’une génératrice à l’intérieur PEUT VOUS TUER EN QUELQUES MINUTES. Les génératrices
produisent du monoxyde de carbone, un gaz mortel incolore et inodore.
Usar un generador en el interior PUEDE MATARLO EN POCOS MINUTOS. Los gases de escape del
generador contienen monóxido de carbono. Es un veneno que no puede verse ni olerse.
NEVER use inside a home or garage, EVEN IF doors and
windows are open.
NE JAMAIS utiliser à l’intérieur d’une maison ou d’un
garage, MÊME SI les portes et les fenêtres sont ouvertes.
NUNCA lo use dentro de su hogar o del garaje, INCLUSO
con las puertas y las ventanas abiertas.
Only use OUTSIDE and far away from windows, doors,
and vents.
Utiliser uniquement À L’EXTÉRIEUR et loin des fenêtres,
des portes et des évents.
Sólo utilícelo AL AIRE LIBRE y lejos de ventanas, puertas
y respiraderos.
Avoid other generator hazards.
Éviter d’autres dangers associés aux génératrices.
Evite otros peligros provocados por el generador.
READ MANUAL BEFORE USE.
LIRE LE MANUEL AVANT D’UTILISER L’APPAREIL.
LEA EL MANUAL ANTES DE USARLO.
MOVE GENERATOR TO SAFE OPERATING
LOCATION
Make The Most Of Your Purchase!
Go to www.homelite.com and register your
new product on-line.
For any questions about operating or maintaining your product, call
the Homelite Help Line!
Your product has been fully tested prior to shipment to ensure your
complete satisfaction.
To register your Homelite product or set up your eBox
™
account by regular mail, please
print the following information on a 3"x5" card or standard postcard: your name, mailing
address, phone numbers, email address, Homelite product(s) purchased with item number
from package, and serial number for each product. Mail the card to: Homelite Consumer
Products, Attn. Homelite Registration, 1428 Pearman Dairy Road, Anderson, SC 29625.
To receive information on our company and products, please include the following state-
ment on your registration card: “Send me information on your products and company
using the contact information I am providing with this product registration.”
For questions or clarication on these Quick Start Guide
instructions, contact us at 1-800-242-4672.
Productstyleandcongurationmayvary.
Figure 1

Homelite HG1800 Specifications

General

Type	Portable Generator
Starting System	Recoil Start
Fuel Type	Gasoline
Max AC Output	1800 watts
Rated AC Output	1500 watts
AC Voltage	120V
AC Frequency	60Hz
Engine Type	4-Stroke
Outlets	2 x 120V AC
Noise Level	68 dBA

Summary

General Safety Warnings

Carbon Monoxide Hazard

Generator exhaust contains poisonous carbon monoxide gas that can cause unconsciousness or DEATH. Operate in well ventilated, outdoor areas.

Electrical Shock Hazard

Generator is a potential source of electric shock. Do not expose to moisture, rain or snow. Do not operate with wet hands or feet.

Grounding Hazard

Failure to properly ground generator can result in electrocution, especially if the generator is equipped with a wheel kit.

Environmental Exposure Warning

Do not expose to rain or use in damp locations.

Unpack and Prepare Generator

Unpack Generator

Remove inner packaging and lift unit out of carton. Check for included items.

Add Fuel and Check Lubricant

Add 18 oz. 10W30 lubricant and fill with regular unleaded fuel to 1/4 inch below tank top.

Move to Safe Operating Location

Move generator outside to a flat, level surface, away from doors, windows, and vents.

Starting and Operating the Generator

Start Generator Procedure

Turn fuel valve ON, move choke fully right, set switch ON, pull starter rope until resistance is felt, then pull rapidly.

Power Control Panel Usage

Connect loads to receptacles using grounded cords. Use 12V DC cable for 12V receptacle.

Shut Down and Storage

Shut Down Procedure

Unplug loads, run engine for 2 minutes, turn switch OFF, then turn fuel valve OFF.

Long-Term Storage

Refer to operator's manual for storage instructions if storing for longer than 30 days.

Support and Registration

Product Registration

Register your new product online at Homelite.com or by mail to receive product information.

Contact for Assistance

Call 1-800-242-4672 for questions about operating or maintaining the product.