Human HumaStar 300 - User Manual

To Next Page

HumaStar 300

Service Manual

Cat No. 17901s/2

Main Page

Default Chapter5
- Table of Contents5
- Introduction19
- Safety Instructions19
- User Warranty19
- General Safety Warnings20
- Intended Use of the Instrument20
- Disposal Management Concept21
- Instrument Disinfection21
- Biohazard Warning22
- General Description25
- Main Characteristics25
- The Analyzer - Humastar 30025
- Operation28
User Warranty29
2.1 General Description29
2.2 Main Characteristics29
2.3 Operation29
2.5 Installation30
- Installation30
2.6 Assembly Procedure32
2.7 Analyzer Components35
3.2 Main Power Supply Assembly (P/N: Ay0097.04) 2947
3.1 Power Supply Connections (P/N:ei0107.01) 2747
- PCB Power Distribution (P/N: 17970/27)47
- PC Power Supply (P/N: 17956/1)48
- Power Supply + 24V (P/N: 17956/2)49
- Power Supply Maintenance51
3.4 Power Supply Maintenance53
3.3 Power Supply Board (P/N: 17970/7)53
- Replacement of the PC Power Supply53
- Fuse Replacement54
- Replace Power Supply + 24V55
- Spare Parts59
- Enclosed Documentation61
- Interface Pump - Valves (P/N: 17970/24)73
- Maintenance75
- Trouble Shooting Guide76
- Spare Part List78
- Power Supply Photometer Lamp (P/N: 17970/10)85
- Trouble Shooting Guide86
- Enclosed Documentation87
Cpu Slave (P/N:17970/8)92
Mother Board (P/N: 17970/9)100
- Maintenance103
- Trouble Shooting Guide104
- Spare Part List107
- Enclosed Documentation108
- Diluter Driver (P/N: 17970/11)115
- Maintenance117
- Trouble Shooting Guide118
- Spare Part List119
B Motor Control Motor (P/N: 17970/26)123
B Motor Control (P/N: 17970/26)125
- Maintenance Control Motor Assembly129
- Trouble Shooting Guide130
- Spare Part List132
- Enclosed Documentation133
- Data Processing of the Optical Signal145
9.1 Preamplifier (P/N: 18720/8)146
Converter A/D (P/N: 17970/19)146
Photometer (P/N:17970/30)148
- Maintenance149
- Trouble Shooting Guide150
- Spare Part List153
- Persistaltic Pump Driver (P/N: Eb0033.XX)159
- Maintenance162
10.1 Linear Pump Driver (P/N:eb0122.01)163
- Replacement of the Linear Pump Driver Board P6163
- Spare Part List165
- Encoder Motore175
- Maintenance180
- Trouble Shooting Guide181
- Spare Part List182
- Enclosed Documentation183
- Liquid Level Sensor (P/N:17970/31)189
- Maintenance190
- Trouble Shooting Guide191
- Spare Part List192
- Maintenance197
- Trouble Shooting Guide198
- Enclosed Documentation199
- Computer Module (P/N: Ay0096.01, P/N: Ay0199203
- Passive Board 6 Slot Isa Bus (P/N: 17810/7)205
10.2 Maintenance163
14.3 Multi - Serial Port (P/N: 910.002.031)206
14.2 Passive Board 6 Slot Isa Bus (P/N: 17810/7) 187206
14.1 Computer Pc Master (P/N: 17889)206
- Check and the Configuration Multi-Serial Board Parameters206
- Configuration of Bios208
- To Install Software from CD-Rom to Hard Desk211
14.5 to Install Software from CD-Rom to Hard Desk 193212
14.4 Configuration of Bios212
- To Save the SW Archives212
- To Restore HW213
14.6 Maintenance214
- To Replace the Multi-Serial Board214
- Spare Part List217
- Miscellaneous219
- Maintenance221
15.5 Maintenance224
15.4 Thermostat (P/N: Ay0131.01)224
- Thermostat224
- Cooling System226
- Trouble Shooting Guide230
- Spare Part List231
- Enclosed Documentation232
- Hydraulic System (P/N: Hy0012239
- Hydraulics of Washing and Drying the Cuvettes240
16.5 Maintenance241
16.4 Waste Hydraulics241
- Peristaltic Pumps241
- Trouble Shooting Guide244
- Spare Part List246
- Enclosed Documentation247
- Test Program253
- Diagnostic Utility254
- To Run Diagnostics Using the Tester.exe255
17.3 to Run Diagnostics Using the Tester.exe 237256
17.2 Diagnostic Utility256
- Utility Reagent System256
- Utility Reaction Cuvette - Measuring System262
- Utility of the Sampling System267
- Printmeth.exe271
17.4 Printmeth.exe274
- Satsmith.exe274
- Savedbchem.exe275
- Communication Protocol276
17.7 Communication Protocol277
17.6 Savedbchem.exe277
- Host Computer Setup277
- Transfer of a Worklist (Reception from Host)278
- Transferring Results to Host Computer280
- Maintenance285
18.2 Operating Program Checks286
18.1 Preface286
- Reagent System286
- Sampling System287
- Reaction and Measurement System Checks288
- Deviced for Maintenance290
18.3 Deviced for Maintenance291
- To Remove Casing291
18.4 Photometer Module295
- To Equalize and Replace Filters295
- Replace Motor and Belt298
- Replace and Clean Lenses299
18.5 Temperature Adjustment and Control301
- Check Temperature in the Reagent Chamber301
18.6 Preparation System302
- Sampling Arm, Vertical Movement (Probe)302
- Sampling Arm, Rotational Movement304
- Reagent Chamber308
- Sample Plate311
- Measurement System314
18.7 Measurement System315
- Check Reaction and Measurement Plate315
- Cuvette Washing Arm321
- Programmed Maintenance326
18.8 Programmed Maintenance327
- Every Two Weeks327
- Every Six Months or When Necessary328
- General Trouble Shooting Guide331
- Problems with Diluter332
- Temperature Problems333
- Problems with Unreliable Results334
- Preparation Problems336
- Problems with Level Sensors and Mixer337
- Problems Cooling System339
- Problems with Pumps and Valves340
- Problems with Printer341
- Warning Signals, Alarms and Flags342
- Accessories and Spare Parts345
- Electronic Boards346
20.3 Cable Kit Master Computer (P/N: Kg0058.01) 329347
20.2 Electronic Boards347
20.1 Accessories and General Spare Parts347
- Fuses347
- General Spare Parts348
- Complete Modules349
- Flat Cables in Movement350
20.12 Calbes Unipolar351
20.11 Flat Cables Fixed351
20.10 Flat Cables in Movement351
- Motors351
- Encorder Assemblies352
- Optional Modules357
21.1 Bar Code Reader358
- Assembly Procedure and Maintenance358
- Bar Code Reader Optical Alignment360
- Trouble Shooting Guide365
- Spare Part List366
- Documentation367
21.3 Ise Module (P/N: Kg0019.04)371
21.2 Documentation371
- Some Highlights and Specifications371
- Power Supply for the ISE Module377
- The ISE Module Parts378
- Mounting and Connecting379
- Operative Procedure383
- Urine Determination384
- Trouble Shooting Guide389
- Spare Part List391
- Documentation394

Need help?

Do you have a question about the Human HumaStar 300 and is the answer not in the manual?

Human HumaStar 300 Specifications

General

Brand	Human
Model	HumaStar 300
Category	Measuring Instruments
Language	English

Related product manuals

Human HumaClot Junior

28 pages

Human Elisys Quattro

88 pages

Human HumaStar 300 - User Manual

Table of Contents

Human HumaStar 300 Specifications

Related product manuals