Husky H2G3TK - Operation and Safety Checks; Draining the Air Tank; Checking the Safety Valve

/0%2!4)/.
$2!).).'4(%4!.+
3EE&IGURE
4OHELPPREVENTTANKCORROSIONANDKEEPMOISTUREOUT
OFTHEAIRUSEDTHETANKOFTHECOMPRESSORSHOULDBE
DRAINEDDAILY
4ODRAIN


2OTATEDRAINVALVELEFTTOOPEN
 +EEPTHECOMPRESSORTILTEDUNTILALLMOISTUREHAS
BEENREMOVED
 (OLDINGTHEHANDLETILTTHECOMPRESSORTOWARDTHE
DRAINVALVESOTHATITSSETINALOWERPOSITION


$RAINMOISTUREFROMTANKINTOASUITABLECONTAINER
 ./4% #ONDENSATEISAPOLLUTINGMATERIALANDSHOULDBE
DISPOSEDOFINCOMPLIANCEWITHLOCALREGULATIONS
 )FDRAINVALVEISCLOGGEDRELEASEALLAIRPRESSUREREMOVE
ANDCLEANVALVETHENREINSTALL
7!2.).'
5NPLUGTHEAIRCOMPRESSORANDRELEASEALLAIRFROM
THETANKBEFORESERVICING&AILURETODEPRESSURIZETANK
BEFOREATTEMPTINGTOREMOVEVALVEMAYCAUSESERIOUS
PERSONALINJURY
 2OTATEDRAINVALVERIGHTUNTILTIGHTLYCLOSED
#(%#+).'4(%3!&%496!,6%
3EE&IGURE
$!.'%2
$ONOTATTEMPTTOTAMPERWITHTHESAFETYVALVE!NY
THINGLOOSENEDFROMTHISDEVICECOULDFLYUPANDHIT
YOU&AILURETOHEEDTHISWARNINGCOULDRESULTINDEATH
ORSERIOUSPERSONALINJURY
4HESAFETYVALVEWILLAUTOMATICALLYRELEASEAIRIFTHEAIR
RECEIVERPRESSUREEXCEEDSTHEPRESETMAXIMUM4HEVALVE
SHOULDBECHECKEDBEFOREEACHDAYOFUSEBYPULLINGTHE
RINGBYHAND
 4URNTHEAIRCOMPRESSORONANDALLOWTHETANKTOFILL
4HECOMPRESSORWILLSHUTOFFWHENTHEPRESSUREREACH
ESTHEPRESETMAXIMUM
 4URNTHEAIRCOMPRESSOROFF
 0ULLTHERINGONTHESAFETYVALVETORELEASEAIRFORTHREE
TOFIVESECONDS
 2ELEASETHERING!IRMUSTIMMEDIATELYSTOPESCAPING
WHENTHERINGISRELEASED!NYCONTINUEDLOSSOFAIR
AFTERRELEASINGTHESAFETYVALVERINGINDICATESAPROBLEM
WITHTHESAFETYVALVE$ISCONTINUEUSEANDSEEKSERVICE
BEFORECONTINUEDUSEOFTHEAIRCOMPRESSOR
&IG
&IG
3!&%49
6!,6%
$2!).
6!,6%
7!2.).'
)FAIRLEAKSAFTERTHERINGHASBEENRELEASEDORIFTHE
VALVEISSTUCKANDCANNOTBEACTUATEDBYTHERING$O
.OTUSETHEAIRCOMPRESSORUNTILTHESAFETYVALVEHAS
BEENREPLACED5SEOFTHEAIRCOMPRESSORINTHISCONDI
TIONCOULDRESULTINSERIOUSPERSONALINJURY
Fig. 10
DRAIN
VALVE
SAFETY
VALVE
14
Fig. 11