To Next Page

120-334E-R1

| 1

 Note

Ifconvertingtopropane,orderthePropaneConversionPartskit(IBCPart#P-1201)fromyourauthorizedIBC

distributor.

UsetheNaturalGasConversionkitifthefuelsourceatthesiteusesnaturalgasandthemodulatingboilerhasbeenset

up(factoryfire-tested)tooperatewithpropane.Checktheratingplateontheboilertoseewhichfuelsourcetheparticular

boilerhasbeensetupwith.

Usingthisconversionkit,aqualifiedtechnicianwillneedto:

1. Performafuelconversion.

2. Performacombustiontest.

3. Fillintheinformationrequiredonthefuelconversionlabels,andaffixthemtotheboileraftertheconversionis

completed.

Warning

Thisconversionkitshallbeinstalledbyaqualifiedserviceagencyinaccordance

withthemanufacturer’sinstructionsandallapplicablecodesandrequirementsof

theauthorityhavingjurisdiction.Iftheinformationintheseinstructionsisnot

followedexactly,afire,anexplosionorproductionofcarbonmonoxidemayresult

causingpropertydamage,personalinjuryorlossoflife.

Thequalifiedserviceagencyisresponsiblefortheproperinstallationofthiskit.The

installationisnotproperandcompleteuntiltheoperationoftheconvertedappliance

ischeckedasspecifiedinthemanufacturer’sinstructionssuppliedwiththekit.

Theboilerwillautomaticallyde-ratethemaximuminputatarateofapproximately2%per1,000'above4,500'.Thegas

valveszerogovernorwillensurethatthegas-airmixtureisnotaffectedataltitude.

Includedwiththeconversionkit:

1xNGMixerAssembly-IBCPart#180-254 4xHexboltM6x14SS-IBCPart#150-373

1xO-ringgasvalvecoupler-IBCPart#150-001 1xRatingPlateFuelOverlay-IBCPart#080-285A

4xHexboltM5x25IBCPart#150-354 1xGasValveConversionLabel-IBCPart#080-107B

4xFlatWasher,0.562ID-IBCPart#150-025 1xInstallerIdentifierLabel-IBCPart#080-283A

4xM6FlatWasherIBCPart#150-159 6xHexboltM8x14-IBCPart#150-329

6xM8Flatwasher-IBCPart#150-339 1xO-ringEBMblower-IBCPart#150-376

Thisconversioninvolveschangingthemixingassembly.

EX 700 - Fuel Conversion to Natural Gas

(LP to NG) P-Kit 1200

IBC EX 850 Quick Start Guide

Other manuals for IBC EX 850