Jetson FWCD Series

To Next Page

To Previous Page

Jetson

www.JetsonHVAC.com

the material. It's used for reconditioning of

waterborne systems. The product is mild to user,

material and the environment.

Main Page

Introduction3
Table of Contents6
Digits 5 to 7 - Nominal Capacity12
Digit 8 - Unit Voltage12
Digit 9 - Unit Application12
Digit 10 - Refrigerant Style12
Digit 11 - Number of Circuits12
Digit 12 - Efficiency/Capacity13
Digit 13 - Design Sequence13
Digit 14 - Array System13
Digit 15 - Evaporator Heat Exchanger Type13
Digit 16 - Evaporator Fluid Type13
Digit 17 - Evaporator Flow13
Digit 18 - Evaporator Temperature Range14
Digit 19 - Evaporator Control Valves14
Digit 20 - Condenser Heat Exchanger Type14
Digit 21- Condenser Fluid Type14
Digit 22 - Condenser Heat Recovery15
Digit 23 - Condenser Corrosion Resistance15
Digit 24 - Condenser Control Valves15
Digit 25 - Power Feed15
Digit 26 - Power Connection16
Digit 27 - Service Options17
Digit 28 - Panel Ampere Rating17
Digit 29 - Control Style17
Digit 30 - Local Unit Controller Interface18
Digit 31 - Remote BMS Interface (Digital Comm)18
General Information23
Unit Components25
Pre-Installation26
Electrical Service Sizing Data27
Dimensions29
Clearances35
Weights38
Application Information39
- Line Sizing Guidelines45
Installation Mechanical49
- Clearances50
- Ventilation50
- Drainage50
- Handling50
- Forklifting Procedure51
- Rigging Procedure51
- Access Restrictions52
- Compressor Mounting52
- Direct Mounting52
- Unit Leveling52
- Typical Water Piping52
- Avoidance of Short Water Loops52
- Minimum Water Volume for a Process Application53
- Unit Piping53
- Exchanger Water Pressures53
- Flow Sensing Devices53
- Water Piping Recommendations53
- Water Flow Rates54
- Chilled Water System Volume54
- Pressure Drop Curves55
- Water Treatment58
- Evaporator and Water Piping58
- Condenser Piping60
Installation Electrical61
- General Recommendations61
- Checking the Power Supply61
- Total Supply Voltage62
- Voltage Imbalance between Phases62
- Equipment Grounding62
- Unit Power Wiring62
- Scroll Compressor Electrical Phasing63
- Setting the Proper Electrical Phase Sequence63
- Control Power Supply63
- External Contacts and Peripherals64
- Required Chilled Water Flow Switch64
- Condenser Water Loss of Flow Protection64
- Required Pump Control64
- Remote Off/Auto64
- Remote Alarm64
Smart Controls65
Controls Interface69
- Unit Controller - General69
Unit Controller69
- Software Installation and Setup69
- Downloading and Installing Unit Controller (MCS-Connect) Software69
- Connecting to the Chiller70
- Setpoint Changes70
- Viewing and Troubleshooting ALARMS70
- Downloading and Viewing Graphs70
- Updating Chiller Software and Configuration Files70
Unit Start-Up Procedures72
- Pre-Start72
- Sequence of Operation73
- Checking Operating Conditions73
- System Superheat74
- System Subcooling74
Shut down75
- Normal Unit Shutdown75
- Extended Shutdown Procedure75
Unit Restart75
- Unit Restart after Extended Shutdown75
Maintenance77
- Periodic Maintenance77
- Weekly Maintenance77
- Monthly Maintenance77
- Annually78
Compressor Maintenance78
- Compressor Oil78
- Oil Level78
- Oil Appearance78
- Scroll Compressor Functional Test78
- Compressor Operational Noises79
- Excessive Amp Draw79
- Low Suctions79
Heat Exchanger Maintenance79
- When to Clean a Brazed Plate Heat Exchanger (BPHE)79
- How to Clean a Brazed Plate Heat Exchanger (BPHE)79
- Cleaning in Place (CIP) Procedure79
- CIP Fluids80
- Bio Gen Active - Scale 132 Copper80
- Organic Acids80
- Formic Acid80
- Acetic Acid80
- Citric Acid80
- Bases80
- Commercially Available Cip Fluids80
Wiring82
- Appendix A93
- Warranty93
- Appendix B95
- Piping System Flushing Procedure95
- Water Treatment Requirements95

Jetson FWCD Series - Page 81

Table of Contents