JMPosner SQ1 - Fountain Assembly; Fountain Components

4
FOUNTAIN ASSEMBLY INSTRUCTIONS
FOUNTAIN COMPONENTS
1. Top Hat –Fitsontopofthecentrecolumnandholdsthemetalscrewinthemiddle.
2. Tiers–3differentsizes,slidesdownthecentrecolumntorestintoplace.
a.)SmallTier(Top)
b.)MediumTier(Middle)
c.)LargeTier(Bottom)
d.)ExtensionTier(Smallest),suppliedwith5”extension;purchasedseparately.
3. 5”ExtensionPiece.Youhavetopurchasethisseparately,
4. Centre Column extension–Restsontopofthecentrecolumn.Wherethemiddle&top
tierssits.
5. Centre Column–Restswithinthecentrehousinginthemiddleofthebasin.
6. Auger Extension-Sitsontopofthemetalscrewinsidethecentrecolumnextension.
7. Auger–Sitsonthesquaremetalshaftinthemiddleofthebasininsidethecentre
column.
8. Centre Housing–Supportscentrecolumn.Fixedtofountainbasin.
9. Removable Basin (not including SQ1)–Whichsitsontopofthedrumandholdsthe
centrecolumnandscrew.Donotplaceitinthedishwasher.
10. Drum–Thisisthebottomofthefountain.Ithousesalloftheelectricalcomponents,
includingthemotorunit.Onlytobeopenedbyaqualiedperson.
a.)Theventholesallowhotairproducedbythemotorandheatingelementsto
escape,coolingtheelectricalcomponents.Ventholesshouldnotbecovredduring
use
11. Membrane Switch (SQ1)–Thecontrolpanelsystemmaintainsheatertemperatureto
between45to55degreesCentigradeandswitchesthemotoronandoffasrequired.
TheHeaterontheSQ1ispresetandyoucannotchangethetemperatureThereare
3LEDindicators.TheHeaterlightcomesonwhenyouswitchonthefountainandit
willstayonuntilthetemperaturereaches55degreesanditwillgooffasthecontrol
panelcutsofftheheateranditwillcomesonagainwhenthetemperaturereaches45
Degrees.Thiscyclewillcontinuetillyouswitchofftheswitch.Themotorlightwillcome
onwhenthemotorisswitchedon.Pleasenotethemotorwillonlyturnononcethe
Indictorstopsashing.Themembraneswitchpanelhasapush-buttoncommandthe
ON/OFFstateofthemotor.
Membrane Switch (SQ2 & SQ3)–Thecontrolsystemswitchesthechocolateheater
onandofftomaintainthetemperatureatapre-setlevel,andswitchesthemotor
onandoffasrequired.ThereisatwodigitLEDdisplaytoindicatethetemperature
indegreesCentigrade,andalsotwoindividualLEDindicatorswhichlightwhenthe
heaterandmotorrespectivelyareON.Themembraneswitchpanelhasapairofpush-
buttonswitchesforUPandDOWNcontrolofthetemperature,andathirdpush-button
commandstheON/OFFstateofthemotor.
12. Fuse–Themachinehas3fuses.1stfuseisinthepowercord.2ndfuseisinthepower
socketonthedrumandthe3rdfuseisonthePCBboardinsidethedrum.Onlya
qualiedelectricianshouldreplacethefuseinthePCBboard.
13. Adjustable Feet–Screwintothebottomofthebase.Thesemaybetightened
orloosenedtoraiseorloweraparticularsideofthefountainforleveling.