Johnson Controls Hitachi MW-NP902A3 User Manual

2
Signal Words
Indicates a hazardous situation that, if not avoided, could result in death or
serious injury.
Indicates a hazardous situation that, if not avoided, could result in minor or
moderate injury.
Indicates information considered important, but not hazard-related
(for example, messages relating to property damage).
General Precautions
To reduce the risk of serious injury or death, read these instructions thoroughly and
follow all warnings or cautions included in all manuals that accompanied the product
and are attached to the unit. Refer back to these safety instructions as needed.
Ɣ 7KLVV\VWHPVKRXOGEHLQVWDOOHGE\SHUVRQQHOFHUWL¿HGE\-RKQVRQ&RQWUROV+LWDFKL$LU&RQGLWLRQLQJ3HUVRQQHO
PXVWEHTXDOL¿HGDFFRUGLQJWRORFDOVWDWHDQGQDWLRQDOEXLOGLQJDQGVDIHW\FRGHVDQGUHJXODWLRQV,QFRUUHFW
LQVWDOODWLRQFRXOGFDXVHOHDNVHOHFWULFVKRFN¿UHRUH[SORVLRQ,QDUHDVZKHUH6HLVPLFµ¶3HUIRUPDQFH
UHTXLUHPHQWVDUHVSHFL¿HGWKHDSSURSULDWHPHDVXUHVVKRXOGEHWDNHQGXULQJLQVWDOODWLRQWRJXDUGDJDLQVW
possible damage or injury that might occur in an earthquake if the unit is not installed correctly, injuries may
occur due to a falling unit.
Ɣ Use appropriate Personal Protective Equipment (PPE), such as gloves and protective goggles and, where
appropriate, have a gas mask nearby. Also use electrical protection equipment and tools suited for electrical
RSHUDWLRQSXUSRVHV.HHSDTXHQFKLQJFORWKDQGD¿UHH[WLQJXLVKHUQHDUE\GXULQJEUD]LQJ8VHFDUHLQKDQGOLQJ
rigging, and setting of bulky equipment.
Ɣ When transporting, be careful when picking up, moving and mounting these units. Although the unit may be
packed using plastic straps, do not use them for transporting the unit from one location to another. Do not stand
on or put any material on the unit. Get a partner to help, and bend with your knees when lifting to reduce strain
RQ\RXUEDFN6KDUSHGJHVRUWKLQDOXPLQXP¿QVRQWKHDLUFRQGLWLRQHUFDQFXW¿QJHUVVRZHDUSURWHFWLYH
gloves.
Ɣ Do not touch or adjust any safety devices inside the indoor or outdoor units. All safety features, disengagement,
and interlocks must be in place and functioning correctly before the equipment is put into operation. If these
devices are improperly adjusted or tampered with in any way, a serious accident can occur. Never bypass or
jump-out any safety device or switch.
Ɣ Johnson Controls-Hitachi Air Conditioning will not assume any liability for injuries or damage caused by not
IROORZLQJVWHSVRXWOLQHGRUGHVFULEHGLQWKLVPDQXDO8QDXWKRUL]HGPRGL¿FDWLRQVWR-RKQVRQ&RQWUROV+LWDFKL$LU
Conditioning products are prohibited as they…
ƕ May create hazards which could result in death, serious injury or equipment damage;
ƕ Will void product warranties;
ƕ 0D\LQYDOLGDWHSURGXFWUHJXODWRU\FHUWL¿FDWLRQV
ƕ May violate OSHA standards;
Take the following precautions to reduce the risk of property damage.
Ɣ Be careful that moisture, dust, or variant refrigerant compounds not enter the refrigerant cycle during installation
work. Foreign matter could damage internal components or cause blockages.
Ɣ ,IDLU¿OWHUVDUHUHTXLUHGRQWKLVXQLWGRQRWRSHUDWHWKHXQLWZLWKRXWWKHDLU¿OWHUVHWLQSODFH,IWKHDLU¿OWHULVQRW
installed, dust may accumulate and breakdown may result.
Ɣ Do not install this unit in any place where silicon gases can coalesce. If the silicon gas molecules attach
WKHPVHOYHVWRWKHVXUIDFHRIWKHKHDWH[FKDQJHUWKH¿QQHGVXUIDFHVZLOOUHSHOZDWHU$VDUHVXOWDQ\DPRXQWRI
GUDLQDJHPRLVWXUHFRQGHQVDWHFDQRYHUÀRZIURPWKHFRQGHQVDWHSDQDQGFRXOGUXQLQVLGHRIWKHHOHFWULFDOER[
possibly causing electrical failures.
Ɣ When installing the unit in a hospital or other facility where electromagnetic waves are generated from
nearby medical and/or electronic devices, be prepared for noise and electronic interference Electromagnetic
Interference (EMI). Do not install where the waves can directly radiate into the electrical box, controller cable, or
controller. Inverters, appliances, high-frequency medical equipment, and radio communications equipment may
FDXVHWKHXQLWWRPDOIXQFWLRQ7KHRSHUDWLRQRIWKHXQLWPD\DOVRDGYHUVHO\DႇHFWWKHVHVDPHGHYLFHV,QVWDOOWKH
unit at least 10 ft. (approximately 3m) away from such devices.

Johnson Controls Hitachi MW-NP902A3 Specifications

General

Brand	Johnson Controls
Model	Hitachi MW-NP902A3
Category	Air Conditioner
Language	English