Kenmore 153.552500 - User Manual

1
Kenmore®
Gas Water Heater
For potable water heating only.
Not suitable for space heating.
Not for use in mobile homes.
INSTALLER: Affix these instructions to or near
the water heater.
OWNER: Retain these instructions for future
reference.
FOR YOUR SAFETY: An odorant is added to
the gas used by this water heater.
Si no puede leer o entender el inglés y necesita el manual de
instrucciones en español, puede solicitarlo al 1-800-821-2017. NO
TRATE DE INSTALAR U OPERAR ESTE CALENTADOR DE AGUA
SI NO ENTIENDE LAS INSTRUCCIONES. No hacer caso de esta
advertencia podría originar lesiones graves o mortales.
ADVERTENCIA
LOW LEAD
C
O
NTENT
Use & Care Guide
Model No.
153.552400 40 Gallon Tall
153.552500 50 Gallon Tall
P/N 100264212 (0315)
Sears Brands Management Corporation,
Hoffman Estates, IL 60179 U.S.A.
www.kenmore.com

Summary

Safe Installation, Use, and Service

General Safety Precautions

Provides general safety guidelines and warnings for water heater installation and operation.

Safety Warnings and Hazards

Explosion Hazard Warning

Warns about the risk of water tank explosion due to overheating and pressure buildup.

Carbon Monoxide and Ventilation Hazard

Details the risks of carbon monoxide gas and requirements for proper venting and air supply.

Installation Instructions

Location Considerations and Safety

Facts to Consider About the Location

Guidelines for choosing a safe and suitable location for the water heater.

Fire and Explosion Hazard Warning

Details fire and explosion risks related to location and flammable materials.

Fire Hazard from Flooring

Ventilation, Air Supply, and Insulation Safety

Fire;Explosion Hazard and Clearances

Details fire and explosion risks and required clearance distances from combustible surfaces.

Carbon Monoxide Hazards

Warns about carbon monoxide risks and the importance of proper venting and air intake.

Water Piping and Scald Prevention

Water Piping Connection Guidance

Scald Hazard from Hot Water

Alerts to severe burn risk from hot water and recommends mixing valves for safety.

Temperature-Pressure Relief Valve

Explosion Hazard from Valve Failure

Warns of explosion risk if the T&P relief valve is not properly installed or functioning.

Severe Burn Hazard from Hot Water

Reiterates the risk of severe burns from hot water discharge.

Venting, Filling, and Safety Precautions

Vent System Safety Warnings

Warns about carbon monoxide from improper venting and corrosive chemicals affecting the vent.

Gas Piping and Venting Safety

Fire and Explosion Hazards in Gas Piping

Details risks associated with gas supply type, pressure, and potential leaks.

Carbon Monoxide and Chemical Hazards

Warns about carbon monoxide from flue gas and chemical vapor corrosion of vent systems.

Gas Piping and Sediment Traps

Fire and Explosion Hazards in Gas Lines

Warns about contaminants in gas lines causing fire or explosion and proper installation.

Operating Instructions: Lighting the Pilot

Lighting the Pilot and Burner

Step-by-step guide for lighting the pilot and main burner safely.

Safety Before Lighting and Operation

Critical Safety Warnings Before Lighting

Crucial safety warnings and procedures to follow before lighting the appliance.

Actions for Gas Smells

Detailed procedures to follow if a gas leak is detected.

Pilot and Burner Lighting Procedure

Detailed steps for lighting the pilot and operating the gas control knob.

Temperature Regulation and Scald Prevention

Temperature Regulation Guide

Preventing Scalds from Hot Water

Alerts to severe burn risk from hot water and recommends mixing valves for safety.

Temperature Control System Operation

Burner Door Replacement and Igniter System

Burner Door Assembly Replacement Safety

Warns of fire/explosion risks if the burner door is not properly installed with a good seal.

Gas Control, Housekeeping, and Anode Rod

Housekeeping and Fire Safety

Recommendations for maintaining a clean area around the water heater and fire safety.

Relief Valve Operation and Draining

Temperature-Pressure Relief Valve Operation

Troubleshooting Common Issues

Leakage Checkpoints and Manual Reference

General Safety and Manual Usage

Emphasizes reading the manual before operation and performing safety checks.

Troubleshooting Guide: Specific Problems

Ignition and Pilot Light Issues

Status Light Troubleshooting

Pilot Light Troubleshooting Flowchart

Pilot Light Not Lighting (New Installation)

Pilot Light Goes Out or Wont Remain Lit

Kenmore 153.552500 Specifications

General

Brand	Kenmore
Model Number	153.552500
Capacity	50 Gallons
Fuel Type	Electric
Tank Capacity	50 Gallons
Voltage	240V
Wattage	4500W
Diameter	22 inches
Weight	125 lbs
Warranty	6 years
Type	Electric