Kity 613 - Page 33

32 international
SODFH&KHFNIRUIDXOWVWHHWKFUDFNVEHIRUHXVH'RQRW
XVHIDXOW\VDZEDQGV
 :HDUVXLWDEOHJORYHVZKHQKDQGOLQJVDZEDQGV
 $OOSURWHFWLYHDQGVDIHW\GHYLFHVPXVWEHVHFXUHO\PRXQWHG
RQWKHPDFKLQHEHIRUHEHJLQQLQJZRUN
 1HYHU FOHDQ WKH VDZEDQG RU WKH VDZEDQG JXLGH ZLWK D
KDQGKHOGEUXVKRUVFUDSHUZKLOHWKHVDZEDQGLVUXQQLQJ
5HVLQFRYHUHGVDZEDQGVLPSDLUZRUNLQJVDIHW\DQGPXVW
be cleaned regularly.
 )RU\RXURZQSURWHFWLRQZHDUSURWHFWLYHJODVVHVDQGKHDU-
LQJSURWHFWLRQ:HDUDKDLUQHWLI\RXKDYHORQJKDLU5ROOXS
ORRVHVOHHYHVRYHUWKHHOERZV
 $OZD\VSRVLWLRQWKHVDZEDQGJXLGHDVQHDUWKHZRUNSLHFH
DVSRVVLEOHZKHQZRUNLQJ
 ,QVXUHVXI¿FLHQWOLJKWLQJLQ WKH ZRUNDUHDDQGDURXQG WKH
machine.
 $OZD\V XVH WKH IHQFH IRU VWUDLJKW FXWV WR NHHS WKHZRUN-
SLHFHIURPWLSSLQJRUVOLSSLQJDZD\
 :KHQ ZRUNLQJ RQ QDUURZ ZRUNSLHFHV ZLWK PDQXDO IHHG
XVHWKHSXVKVWLFN
 )RUGLDJRQDOFXWVSODFHWKHVDZEHQFKLQWKHDSSURSULDWH
SRVLWLRQDQGJXLGHWKHZRUNSLHFHRQWKHIHQFH
 ,QVXUHVDIHZRUNSLHFHJXLGDQFH
 )RU DUFHG DQG LUUHJXODU FXWV SXVK WKH ZRUNSLHFH HYHQO\
XVLQJERWKKDQGVZLWKWKH¿QJHUVWRJHWKHU+ROGWKHZRUN-
SLHFHZLWK\RXUKDQGVRQDVDIHDUHD
 8VHDSDWWHUQIRUUHSHDWHGDUFHGRULUUHJXODUFXWV
 ,QVXUHWKDWWKHZRUNSLHFHGRHVQRWUROOZKHQFXWWLQJURXQG
pieces.
 8VHWKHWUDYHUVHFXWWLQJJDXJHVSHFLDODFFHVVRU\IRUVDIHW\
ZKHQPDNLQJWUDYHUVHFXWV
Electrical Connection
7KHLQVWDOOHGHOHFWULFPRWRULVFRQQHFWHGDQGLVUHDG\WRZRUN
7KH FRQQHFWLRQ FRPSOLHV ZLWK WKH UHOHYDQW 9'( DQG ',1
regulations.
The customer-side mains supply and the used extension line
must meet these regulations.
,QVWDOODWLRQV UHSDLU DQG PDLQWHQDQFH ZRUN UHODWLQJ WR WKH
electric installation may only be performed by specialists.
Important Notes
7KHHOHFWULFPRWRUKDVEHHQGHVLJQHGIRUWKH6RSHU-
ating mode.
In case of an overload of the motor, it turns off automatically.
$IWHUDFRROLQJSHULRGGXUDWLRQYDULHV\RXFDQWXUQRQWKH
motor again.
'HIHFWLYH(OHFWULF&RQQHFWLRQ/LQHV
Often, insulation damages occur on electrical connection lines.
Causes are:
 'UDJPDUNVLIFRQQHFWLRQOLQHVDUHOHGWKURXJKZLQGRZRU
door clearances.
 .LQNVGXHWRLPSURSHUDWWDFKPHQWRUURXWLQJRIWKHFRQQHF-
tion line.
 &XWVFDXVHGE\UXQQLQJRYHUWKHFRQQHFWLRQOLQH
 ,QVXODWLRQGDPDJHVFDXVHGE\SXOOLQJWKHFRQQHFWLRQOLQH
RXWRIWKHZDOOVRFNHW
 )LVVXUHVFDXVHGE\WKHDJHLQJRIWKHLQVXODWLRQ
Such defective electric connection lines must not be used
and are hazardous due to the insulation damages.
5HJXODUO\FKHFNWKHHOHFWULFDOFRQQHFWLRQOLQHVIRUGDPDJHV
3OHDVHPDNHVXUHWKDWWKHFRQQHFWLRQOLQHVDUHGLVFRQQHFW-
HGIURPWKHPDLQVVXSSO\GXULQJWKHFKHFN
(OHFWULFDO FRQQHFWLRQ OLQHV PXVW FRPSO\ ZLWK WKH UHOHYDQW
9'(DQG',1UHJXODWLRQV2QO\XVHFRQQHFWLRQOLQHVODEHOOHG
ZLWK+517KHODEHOOLQJRIWKHFRQQHFWLRQFDEOHZLWKWKH
W\SHVSHFL¿FDWLRQLVUHTXLUHG
AC motor
 7KHVXSSO\YROWDJHPXVWEH9+]
 ([WHQVLRQOLQHVXSWRDOHQJWKRIPPXVWKDYHDFURVV
VHFWLRQ RI  VTXDUH PLOOLPHWUHV ([WHQVLRQ OLQHV ZLWK D
length of more than 25 m must have a minimum cross sec-
WLRQRIVTXDUHPLOOLPHWUHV
 7KHPDLQVFRQQHFWLRQLVSURWHFWHGZLWKDGHOD\DFWLRQIXVH
of 16 A.
,I\RXKDYHIXUWKHUTXHVWLRQVSOHDVHVSHFLI\WKHIROORZLQJ
 0RWRUPDQXIDFWXUHU
 .LQGRIFXUUHQWRIWKHPRWRU
 'DWDIURPWKHPDFKLQHW\SHSODWH
 'DWDIURPWKHVZLWFKW\SHSODWH
,I\RXUHWXUQWKHPRWRUDOZD\VUHWXUQWKHFRPSOHWHGULYHXQLW
ZLWKWKHVZLWFK
Maintenance
3HUIRUPUHVHWWLQJPHDVXULQJDQGFOHDQLQJZRUNH[FOXVLYHO\
ZKHQWKHPRWRULVWXUQHGRII'LVFRQQHFWWKHPDLQVSOXJDQG
ZDLWXQWLOWKHURWDWLQJWRROVWDQGVVWLOO
All protection and safety devices must be immediately rein-
VWDOOHGRQFHWKHUHSDLUDQGPDLQWHQDQFHZRUNLVFRPSOHWHG
The built-in ball bearings are maintenance-free.
5HFRPPHQGDWLRQV
 6OLJKWO\UHOXEULFDWHWKHVOHZLQJVHJPHQWVRIWKHWDEOHDQG
the bend tensioning device.
 5HJXODUO\FOHDQWKHVDZEDQG:RRGOHDYHVUHVLQVHGLPHQWV
 5HJXODUO\ FKHFN WKH JXLGLQJ UROOHUV DQG WKH FRXQWHUSUHV-
VXUHEHDULQJV ,IUHTXLUHGUHDGMXVW RUGLVDVVHPEOH WKHP
and grease or exchange the parts.
 ([FKDQJHZRUQRXWWDEOHLQVHUWV
 (QVXUHWKDWWKHWDEOHWRSLVDOZD\VIUHHRIUHVLQ
Special Accessories