Kohler Courage SV610

20 590 08 Rev. A
KohlerEngines.com
SV470-SV620
Owner's Manual
IMPORTANT: Read all safety precautions and instructions carefully before
operating equipment. Refer to operating instruction of
equipment that this engine powers.
Ensure engine is stopped and level before performing any
maintenance or service.
Warranty coverage as outlined in the warranty card and on
KohlerEngines.com. Please review carefully as it provides you
specifi c rights and obligations.
To maintain compliance with applicable emission regulations,
exhaust system backpressure may not exceed limits which can
be found on KohlerEngines.com. Search by Model No., select
Read More, then select Specs tab.
Record engine information to reference when ordering parts or obtaining warranty coverage.
Engine Model
Specifi cation
Serial Number
Purchase Date
EN
DE
ES
FR
IT
PT

Kohler Courage SV610 Specifications

General

Compression Ratio	8.5:1
Ignition System	Electronic
Governor Type	Mechanical
Engine Type	4-cycle, OHV, single-cylinder
Power	20 hp
Oil Capacity	1.5 liters
Lubrication	Full Pressure with Full-Flow Filter
Fuel Type	Unleaded Gasoline (Minimum 87 Octane)
Spark Plug Gap	0.030 in. (0.76 mm)

Summary

Safety Precautions

General Safety Warnings

Covers fuel, carbon monoxide, accidental starts, rotating parts, electrical, and hot parts hazards.

California Proposition 65 Warning

Warning about chemicals known to cause cancer and birth defects.

Pre-Start Checklist

Engine Operation

Starting Procedures

Instructions and hints for starting the engine, including cold weather.

Stopping Procedures

Steps to properly stop the engine.

Operating Limits

Information on angle of operation, engine speed, and high altitude considerations.

Maintenance Instructions

Maintenance Schedule

Schedule for routine maintenance tasks based on hours or annually.

Oil Management

Recommendations for oil type and checking the oil level.

Fluid Management

Changing Oil and Filter

Detailed steps for draining and replacing engine oil and filter.

Fuel Recommendations

Guidelines for using appropriate gasoline and fuel additives.

Component Maintenance

Spark Plugs

Instructions for checking, adjusting, and installing spark plugs.

Air Cleaner Service

Procedures for cleaning or replacing the air cleaner element.

Breather Tube Check

Ensuring the breather tube is properly connected.

Air Cooling System

Importance of proper cooling and cleaning external surfaces.

Service and Parts

Information on obtaining authorized service and replacement parts.

Storage Procedures

Steps for storing the engine when out of service for extended periods.

Troubleshooting and Specifications

Troubleshooting Guide

Table of common problems and their possible causes.

Engine Specifications

Key technical data including bore, stroke, displacement, and oil capacity.