Home
Kubota
Tractor
M100GX-II
Kubota M100GX-II User Manual
4
of 1
of 1 rating
209 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
99
HYDRAULIC UNIT
B
Remote Couplers Spillage Collector
With the remote control valve coupler in place, a slight
amount of oil leaking from
the coupler is recovered. In this
way, no oil is splashed around the tractor body.
A
Oil recovered contains dust and water. Do not pour
such oil back into the transmission case.
(1) Collec
tor cap
(2) Oil tan
k
122
124
Table of Contents
Default Chapter
5
Table of Contents
5
Safe Operation
25
Servicing of Tractor
25
Specifications
27
Specification Table
27
Traveling Speeds
29
Implement Limitations
30
Instrument Panel and Controls
38
Pre-Operation Check
43
Daily Check
43
Operating the Engine
44
Exhaust Aftertreatment Devices
44
Diesel Particulate Filter (DPF) Muffler
44
Handling Points
45
DPF Regeneration Process
45
Regeneration Operating Procedure
46
PM Warning Level and Required Procedures
47
Regeneration Operating Procedure
48
PM Warning Level and Required Procedures
49
Tips on Diesel Particulate Filter (DPF) Regeneration
51
Starting the Engine
51
Cold Weather Starting
56
Block Heater (if Equipped)
56
Stopping the Engine
56
Warming up
56
Warm-Up and Transmission Oil at Low Temperature Range
56
Jump Starting
57
Operating the Tractor
58
Operating New Tractor
58
Do Not Operate the Tractor at Full Speed for the First 50 Hours
58
Changing Lubricating Oil for New Tractors
58
Boarding and Leaving the Tractor
58
Starting
58
Operator's Seat
58
Seat Belt
60
Passenger Seat
60
Steering Adjustment
61
Extendable Mirror
61
Light Switch
61
Turn Signal / Hazard Light Switch
61
With Trailer Connector
62
Horn Button
62
Work Light Switch (Front)
62
Work Light Switch (Rear)
62
Brake Pedals (Right and Left)
63
Clutch Pedal
64
Power Shift / Range Shift Lever (PS. Lever)
65
DHC Switch
67
Shuttle Lever
67
Creep Lever (if Equipped)
68
4WD / Bi-Speed Turn Switch [4WD Model]
68
Hand Throttle Lever
69
Foot Throttle
69
Rev-Limiter Control Dial
69
Parking Brake Lever
70
Contents
63
Stopping
70
Check During Driving
70
Immediately Stop the Engine if
70
Easy Checker(TM)
70
Fuel Gauge
71
Coolant Temperature Gauge
72
Tachometer
72
Hour / Trip Monitor
72
Side Digital Display
73
Initial Setting
73
Factory-Set Screen Display
75
Electronic Engine Control
78
Rev-Limiter Control Setting
78
RPM Dual Memory Setting
78
Constant RPM Management Control
80
Auto Mode
82
Outline
82
Operation
84
Work Speed Display
85
Changing the Field Speed
86
Sensitivity Adjustment
87
Changing the Auto-Mode Setting
87
Front Suspension
90
Outline
90
Suspension Switch
90
Ride Condition Damper Switch
92
Manual Control Mode
92
Parking
93
Operating Techniques
93
Differential Lock
93
Rear Wheel Differential Lock Pedal
94
Front Wheel Differential Lock Switch
94
Operating the Tractor on a Road
95
Operating on Slopes and Rough Terrain
95
Transport the Tractor Safely
95
Directions for Use of Power Steering
95
Trailer Electrical Outlet
96
Hydraulic Brake for Trailer
96
Pto
97
Pto Operation
97
PTO Clutch Control Switch
97
PTO Gear Shift Lever
98
PTO Gear Shift Lever
99
1000 Rpm PTO Shaft
99
PTO Shaft Cover and Shaft Cap
100
3-Point Hitch & Drawbar
101
3-Point Hitch
102
Selecting the Holes of Lower Links
102
Adjusting Lateral Float
102
Selecting the Top Link Mounting Holes
102
Drawbar
102
Remote Hitch up / down Switch
103
Lifting Rod
104
Top Link
104
Telescopic Stabilizers
104
Quick Hitch (Hook Type)
104
Drawbar
106
Swing Drawbar
107
High-Hitch
108
Piton-Fix
109
Drawbar
109
Swing Drawbar
109
High-Hitch
110
High-Hitch with Automatic Trailer Coupling
110
High-Hitch with Ball Trailer Coupling
111
Piton-Fix
112
AUTO HITCH (Push Back Type)
112
Auto Hitch
112
Hydraulic Unit
115
3-Point Hitch Control System
115
Terminology
115
Mode Selector Switch
116
Position Control Mode
116
Mixed Draft Control Mode
117
Float Control
117
Bottom Limit Control Dial
118
Lift Arm Top Limit Adjustment Dial
118
3-Point Hitch Lowering Speed Adjustment Dial
118
3-Point Hitch Lowering Lock Lever
118
3-P. Quick Raise / Lower Switch
119
3-Point Hitch's Position Lock
120
Remote Hydraulic Control System
120
Remote Control Valve
120
Remote Control Valve Lever
120
Contents
121
Remote Control Valve Coupler Connecting and Disconnecting
121
Adjusting the Flow Rate
122
Remote Couplers Spillage Collector
123
Hydraulic Control Unit Use Reference Chart
124
Tires, Wheels and Ballast
125
Tires
125
Inflation Pressure
125
Dual Tires
125
Wheel Adjustment
126
Front Wheels (with 4-Wheel Drive)
126
Adjusting Front Wheel Turning Stopper Bolt
127
Rear Wheels
128
Ballast
129
Front Ballast
129
Rear Ballast
130
Maximum Masses
130
Cab Operation
131
Door and Window
131
Locking and Unlocking the Door
131
Opening the Door
131
Rear Window
131
Sun Roof
132
Emergency Exit
132
Dome Light
132
Wiper
132
Front Wiper / Washer Switch
132
Rear Wiper / Washer Switch
133
Using the Wipers in Cold Season
133
Air Conditioner
133
Airflow
133
Air Control Vent
134
Control Panel
134
Operation
135
REAR DEFOGGER with TIMER (if Equipped)
137
Installing the Implement Control Box
137
Electrical Outlet
138
Beacon Light
138
Beacon Light Switch
138
Maintenance
139
Service Intervals
139
Lubricants, Fuel and Coolant
143
Periodic Service
145
How to Open the Hood
145
Hood
145
Side Cover
145
Daily Check
145
Walk Around Inspection
146
Checking and Refueling
146
Checking Water Separator
146
Checking Engine Oil Level
147
Checking Transmission Fluid Level
147
Checking Coolant Level
147
Cleaning Evacuator Valve
148
Cleaning Grill, Radiator and Screen
148
Checking DPF Muffler
150
Checking Brake Pedal
150
Checking Gauges, Meter and Easy Checker(TM)
150
Checking Head Light, Turn Signal / Hazard Light Etc
150
Checking Seat Belt
150
Checking Movable Parts
150
Every 50 Hours
151
Checking Engine Start System
151
Checking Wheel Bolt Torque
152
Checking Tie-Rod Dust Cover
152
Every 100 Hours
152
Lubricating Grease Fittings
152
Cleaning Air Cleaner Primary Element
154
Adjusting Fan Belt Tension
155
Checking Fuel Line
156
Adjusting Brake Pedal
156
Adjusting Parking Brake Lever
157
Checking Battery Condition
157
Adjusting Air-Conditioner Belt Tension
159
Every 200 Hours
159
Checking Radiator Hose and Clamp
159
Checking Oil Cooler Line
161
Checking Intake Air Line
161
Checking Power Steering Line
161
Adjusting Toe-In
162
Draining Fuel Tank Water
162
Cleaning Inner Air Filter
163
Cleaning Fresh Air Filter
163
Every 400 Hours
164
Checking Fan / Air-Conditioner Belt Tension
164
Cleaning Water Separator
165
Cleaning Fuel Solenoid Pump Element
166
Every 500 Hours
167
Changing Engine Oil
167
Replacing Engine Oil Filter
168
Cleaning Pre-Fuel Filter
168
Replacing Fuel Filter
169
Replacing Hydraulic Oil Filter
169
Every 600 Hours
170
Adjusting Front Axle Pivot
170
Adjusting King-Pin Pivot
170
Every 1000 Hours
171
Changing Transmission Fluid
171
Changing Front Differential Case Oil
171
Changing Front Axle Gear Case Oil
172
Removing the Tractor from Storage
182
Troubleshooting
183
Engine Troubleshooting
183
Power Shift/Range Shift Trouble Shooting
185
Options
187
Appendices
188
Side Digital Display
188
Changing the Information Displayed
188
Information Displayed and Its Handling
189
Displaying and Using the Work History
192
Measuring the Distance
194
Changing the Units and Dates
194
Maximum Masses
196
Maximum Permissible Load of the Tire
196
Trailer Load Capacity
197
Index
207
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Kubota M100GX-II and is the answer not in the manual?
Ask a question
Kubota M100GX-II Specifications
General
Brand
Kubota
Model
M100GX-II
Category
Tractor
Language
English
Related product manuals
Kubota M100X
24 pages
Kubota M108S
124 pages
Kubota M105S
124 pages
Kubota M108DC
124 pages
Kubota M126X
24 pages
Kubota M110X
24 pages
Kubota M135X
24 pages
Kubota M110GX-II
209 pages
Kubota M135GX-II
209 pages
Kubota M8540
111 pages
Kubota M7060
145 pages
Kubota M6800
638 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
