Kubota M7040SU - Page 16

To Next Page

To Previous Page

SAFE OPERATION8

Main Page

Table of Contents5
Safe Operation19
Servicing of Tractor19
Specifications20
Specification Table20
Traveling Speeds22
Implement Limitations23
Instrument Panel and Controls25
Pre-Operation Check28
Daily Check28
Operating the Engine29
Starting the Engine29
Cold Weather Starting31
Stopping the Engine31
Warming up31
Warm-Up and Transmission Oil at Low Temperature Range31
Jump Starting32
Operating the Tractor33
Operating New Tractor33
Do Not Operate the Tractor at Full Speed for the First 50 Hours33
Changing Lubricating Oil for New Tractors33
Operating Foldable Rops33
To Fold the ROPS33
To Raise the ROPS to Upright Position34
Adjustment of Foldable ROPS34
Starting35
Operator's Seat35
Seat Belt35
Light Switch35
Turn Signal / Hazard Light Switch36
Brake Pedals (Right and Left)36
Clutch Pedal37
Main Gear Shift Lever38
Range Gear Shift Lever38
Front Wheel Drive Lever38
Hand Throttle Lever39
Foot Throttle39
Parking Brake Lever39
Stopping40
Check During Driving40
Immediately Stop the Engine if40
Easy Checker(TM)40
Fuel Gauge40
Coolant Temperature Gauge41
Tachometer41
Pto Tachometer / Hourmeter42
Changing Display Mode42
PTO Speed Display Mode Switching44
Parking45
Operating Techniques45
Differential Lock45
Operating the Tractor on a Road46
Operating on Slopes and Rough Terrain46
Directions for Use of Power Steering46
Trailer Electrical Outlet46
Electrical Outlet47
Pto48
Pto Operation48
PTO Clutch Control Lever48
LCD Monitor Message49
PTO Shaft Cover and Shaft Cap49
Three-Point Hitch & Drawbar50
3-Point Hitch51
Category 1 & 251
Selecting the Holes of Lower Links51
Selecting the Top Link Mounting Holes51
Drawbar51
Lifting Rod (Right)52
Top Link52
Telescopic Stabilizers52
Drawbar53
Swing Drawbar53
Hydraulic Unit54
3-Point Hitch Control System54
Position Control54
3-Point Hitch Lowering Speed54
REMOTE HYDRAULIC CONTROL SYSTEM (if Equipped)54
Remote Control Valve54
Remote Control Valve Lever54
Remote Control Valve Coupler Connecting and Disconnecting55
Hydraulic Control Unit Use Reference Chart56
Tires, Wheels and Ballast57
Tires57
Inflation Pressure57
Dual Tires57
Wheel Adjustment57
Front Wheels (with Two Wheel Drive)57
Front Wheels (with Four Wheel Drive)59
Rear Wheels60
Ballast61
Front Ballast61
Rear Ballast61
Maintenance63
Service Intervals63
Lubricants, Fuel and Coolant65
Periodic Service67
How to Open the Hood67
Hood67
Daily Check67
Walk Around Inspection67
Checking and Refueling68
Checking Water Separator68
Checking Engine Oil Level68
Checking Transmission Fluid Level69
Checking Coolant Level69
Cleaning Evacuator Valve69
Checking Dust Indicator70
Cleaning Grill and Radiator Screen70
Checking Brake Pedals and Clutch Pedal70
Checking Gauges, Meter and Easy Checker(TM)70
Checking Head Light, Turn Signal / Hazard Light Etc70
Checking Seat Belt and ROPS70
Every 50 Hours71
Checking Engine Start System71
Checking Wheel Bolt Torque71
Every 100 Hours72
Lubricating Grease Fittings72
Cleaning Air Cleaner Primary Element73
Adjusting Fan Belt Tension73
Adjusting Alternator Belt Tension74
Checking Fuel Line74
Adjusting Clutch Pedal74
Adjusting Brake Pedal75
Checking Battery Condition75
Every 200 Hours77
Checking Radiator Hose and Clamp77
Checking Intake Air Line77
Checking Power Steering Line77
Adjusting Toe-In78
Draining Fuel Tank Water79
Every 300 Hours79
Replacing Hydraulic Oil Filter79
Every 400 Hours80
Changing Engine Oil80
Replacing Engine Oil Filter80
Replacing Fuel Filter Element81
Replacing Fuel Filter81
Cleaning Water Separator81
Lubricating Grease Fitting [2WD Model]82
Every 600 Hours82
Changing Transmission Fluid82
Changing Front Axle Gear Case Oil & Front Differential Case Oil82
Adjusting Front Axle Pivot83
Every 800 Hours83
Adjusting Engine Valve Clearance83
Every 1500 Hours83
Checking Fuel Injection Nozzle (Injection Pressure)83
Every 3000 Hours83
Checking Injection Pump83
Every 1 Year83
Replacing Air Cleaner Primary Element and Secondary Element83
Every 2 Years84
Flushing Cooling System and Changing Coolant84
Antifreeze84
Replacing Radiator Hose (Water Pipes)85
Replacing Power Steering Hose85
Replacing Fuel Hose85
Replacing Intake Air Line85
Service as Required85
Bleeding Fuel System85
Replacing Fuse86
Replacing Light Bulb87
Replacing Head Lamp87
Storage88
Tractor Storage88
Removing the Tractor from Storage88
Troubleshooting89
Engine Troubleshooting89
Options90

Kubota M7040SU - Page 16

Table of Contents

Related product manuals