Lawn-Boy Insight 10697 - User Manual

 2005—Lawn-Boy, Inc.
8111 Lyndale Ave., Bloomington, MN 55420, USA
Printed in the USA
All Rights Reserved
Original Instructions (EN)
Register your product at www.lawn-boy.com
Insightt
Lawn Mower
Model No. 10697—Serial No. 250000001 and Up
Form No. 3352-964 Rev B
Operator’s Manual
If you have questions or problems, contact us at www.lawn-boy.com
or call toll free 1-866-216-6032 (US) or 1-866-216-6031 (Canada)
before returning this product.
Introduction
Read this manual carefully to learn how to operate
and maintain your product properly and to avoid injury
and product damage. You are responsible for
operating the product properly and safely.
You may contact Lawn-Boy directly at
www.lawn-boy.com for product and accessory
information, help finding a dealer, or to register your
product.
Whenever you need service, genuine Lawn-Boy
parts, or additional information, contact an Authorized
Service Dealer or Lawn-Boy Customer Service and
have the model and serial numbers of your product
ready. The illustration below identifies the location of
the model and serial numbers on the product. Write
the numbers in the space provided below:
Model #:
Serial #:
m-7915
This manual identifies potential hazards and has
safety messages identified by the following words:
• Danger signals an extreme hazard that will
cause serious injury or death if you do not follow
the recommended precautions.
• Warning signals a hazard that may cause
serious injury or death if you do not follow the
recommended precautions.
• Caution signals a hazard that may cause minor
or moderate injury if you do not follow the
recommended precautions.
This manual uses two other words to highlight
information. Important: calls attention to special
mechanical information and Note: emphasizes
general information worthy of special attention.
Warning
The engine exhaust from this product contains
chemicals known to the State of California to
cause cancer, birth defects, or other reproductive
harm.
Important: This engine is not equipped with a spark
arrester muffler. It is a violation of California Public
Resource Code Section 4442 to use or operate this
engine on any forest-covered, brush-covered or
grass-covered land. Other states or federal areas
may have similar laws.
This spark ignition system complies with Canadian
ICES-002.
The enclosed Engine Owner’s Manual is supplied for
information regarding The U.S. Environmental
Protection Agency (EPA) and the California Emission
Control Regulation of emission systems, maintenance
and warranty. Replacements may be ordered through
the engine manufacturer.
Safety
This lawn mower meets or exceeds the CPSC blade
safety requirements for walk-behind rotary lawn
mowers and the B71.1 specifications of the American
National Standards Institute in effect at the time of
production.
Read and understand the contents of this manual
before the engine is ever started.
This is the safety alert symbol. It is used to
alert you to potential personal injury hazards.
Obey all safety messages that follow this symbol
to avoid possible injury or death.
Improperly using or maintaining this mower
could result in injury or death. To reduce this
potential, comply with the following safety
instructions.
The following instructions have been adapted from
the ANSI/OPEI standard B71.1—2003.

Summary

Introduction

Safety

General Operation

Slope Operation

Children

Service

Safe Handling of Gasoline

Instructions for handling gasoline safely to avoid injury or property damage from its flammability.

Safety;Instruction Decals

Product Overview

Setup

Unfolding the Handle

Steps to unfold and adjust the mower's handle for comfortable operation.

Filling the Engine with Oil

Procedure and specifications for filling the engine with the correct type and amount of oil.

Filling the Fuel Tank

Instructions for filling the fuel tank with fresh unleaded gasoline and fuel stabilizer.

Checking the Engine Oil Level

Adjusting the Cutting Height

Adjusting the Upper Handle Height

Operation

Starting the Engine

Step-by-step guide to starting the lawn mower engine.

Using the Self-propel Drive

Engaging the Blade

Disengaging the Blade

Stopping the Engine

Checking the Blade Brake Clutch

Not Using the Grass Bag

Procedure for testing the blade brake clutch system without using the grass bag.

Using the Grass Bag

Using the grass bag to test the blade brake clutch mechanism.

Mulching the Clippings

Bagging the Clippings

Installing the Grass Bag

Removing the Grass Bag

Side Discharging the Clippings

Installing the Side Discharge Chute

Removing the Side Discharge Chute

Operating Tips

Cutting Grass

Cutting Leaves

Maintenance

Recommended Maintenance Schedule

Schedule of maintenance tasks based on usage intervals (each use, yearly, annual storage).

Preparing for Maintenance

Servicing the Air Cleaner

Changing the Engine Oil

Lubricating the Wheel Gears

Lubricating the Upper Handle

Adjusting the Self-propel Drive

Replacing the Blade

Cleaning the Blade Brake Clutch Shield

Cleaning the Mower

Storage

Preparing the Mower for Storage

Steps to prepare the mower for storage, including fuel and oil management.

Folding the Handle

Removing the Mower from Storage

The Lawn-Boy No-Worry Warranty

Conditions and Products Covered

Details the warranty period for different mower products and accessories.

Limited Warranty for Commercial Use

Specifies the warranty terms for commercial, institutional, or rental use.

Items and Conditions Not Covered

Lists exclusions from the express warranty coverage.

Owner Responsibilities

Outlines the owner's duty to maintain the product as per the manual.

Instructions for Obtaining Warranty Service

Provides steps for contacting dealers and arranging warranty service.

General Conditions

General terms and conditions related to warranty repairs and limitations.

Countries Other than the United States or Canada

Information for customers outside the US and Canada regarding warranty policies.

Lawn-Boy Insight 10697 Specifications

General

Engine Type	4-Cycle
Cutting Width	21 inches
Weight	65 lbs
Drive Type	Self-propelled
Starter	Recoil
Deck Material	Steel
Warranty	2 years
Mulching Capability	Yes
Fuel Tank Capacity	1.6 qt
Wheel Size	8 inches front / 11 inches rear