LEM 200 - General Warnings and Safety; Safety Precautions and User Responsibility; How to Use the Ground Meat Packing System; Loading the Tape Machine

LEM Products • West Chester, OH 45011 • 1-877-536-7763 • lemproducts.com
LEM Products • West Chester, OH 45011 • 1-877-536-7763 • lemproducts.com
2 3
IT IS IMPORTANT TO READ AND UNDERSTAND ALL OF THE INSTRUCTIONS AND SAFEGUARDS PRIOR TO USE
1. Always ensure that the appliance is properly assembled and safely set up before use.
3. CAUTION: This appliance is not recommended for use near or by children or persons with certain disabilities. Set up and
store the appliance out of reach of children. When not in use, store device in a secure and dry place out of reach of children.
15. The appliance is designed for domestic use and not for commercial purposes.
17. Use the appliance with the supplied accessories only. WARNING: The use of attachments not recommended or sold by
the manufacturer may cause injury, damage to personal property, and may void your warranty.
18. WARNING: Do not use while under the inuence of alcohol or drugs (prescription or non-prescription) as these may
impair user’s ability to properly assemble or safely operate the appliance.
19. The manufacturer declines any responsibility in the case of improper use of this product. Improper use of this product
voids the warranty.
23. Thoroughly hand-wash all parts in warm soapy water prior to use. DO NOT SOAK. NOT DISHWASHER SAFE
(discoloration may occur).
24. Tie back loose hair and clothing. Remove neckties, rings, watches, bracelets or other jewelry before operating.
25. Use on a level, stable surface to prevent tipping. Never move the appliance while in use.
26. WARNING: Blade is SHARP! To avoid injury, use extreme caution when handling.
28.
SAVE THESE INSTRUCTIONS
To Load Tape Machine: Insert tape on machine and pull about 6 inches o the roll with the sticky side up. Lay the tape
over the slot in the machine. That’s it! When you push a bag into the slot, the tape will go into the slot and the tape will
seal the bag and be cut o.
To Fill Ground Meat Bags: Grind meat through the coarse plate once. Change the coarse plate to the ne plate. Put a
stung tube over the ne plate and tighten the grinder hub. Slide a meat bag over the stung tube. As you grind with
the ne plate, the meat will go directly through the tube and into the bag. Hold back a little on the bag as it lls to
minimize the amount of air in the bag and to pack the meat tightly. (Air pockets promote freezer burn.) Twist the bag at
the top and insert the twisted portion down into the slot of the tape machine pushing down briskly through the slot. The
machine will apply a tape strip to the twisted bag. That’s all there is to it! Lay bags in the freezer one layer high. The bags
can be stacked, once they are thoroughly frozen. Stacking the bags before they are thoroughly frozen will prevent them
from freezing quickly.
Ask the dealer where you purchased this item for additional supplies of tape, bags and other food processing equipment.
Also available is a 2-inch stung tube designed to make lling ground meat bags or large casings easy. The grinder
stung tubes are available from your dealer of LEM Products.
HOW TO USE
GENERAL WARNINGS AND SAFETY INFORMATION
Part # Discription
1
Tape Thread Wheel
2
Tape Thread Holder
3
Tape Thread Holder Spring
4
Spring Mount
5
Blade Holder
6
Break
7
Break Spring
8
Blade Holder Spring
9
Trim Blade
PARTS LIST
Part # Discription
10
Trim Blade Screw
11
Trimmer Set Front Plate
12
Rubber Feet
13
Housing Screw
14
Trimmer Set Back Plate
15
Tape Holder
16
Cutting Balde Screw
17
Cutting Blade