Scheduled Maintenance Log
51
S CHEDULED M AINTENANCE L OG
❏ Replace engine oil and oil filter
1
❏ Lubricate front axle shaft bushings
(GX 470, LX 470)
❏ Measure brake pad thickness and rotor
runout
❏ Replace active height control system
fluid (LX 470)
❏ Replace brake fluid
❏ Replace engine air filter
❏ Replace transmission fluid
2
❏ Re-torque axle shaft flange bolts (GX 470)
❏ Rotate tires
❏ Inspect the following:
____Active height control system (LX 470)
____Axle shaft boots
____Ball joints and dust covers
____Body ____
____Brake lines and hoses ____
____Charcoal canister (GX 470, LX 470)
3
____Differential oil (GX 470, LX 470)
____Drive belts
____Engine coolant
4
____Engine valve clearance
____Exhaust pipes and mountings
72 Months or 60,000 Miles
1
Reset the oil replacement reminder (“MAINT REQD”)
light after replacing engine oil.
2
Required only if vehicle is operated primarily in desert,
on dirt roads or while towing.
3
Required only for vehicles registered in California,
Massachusetts and New York.
4
Replace only with Genuine Toyota Super Long-Life Coolant
or similar high-quality non-silicate, non-amine, non-borate
ethylene-glycol coolant with long-life hybrid organic acid
technology (i.e., a combination of low phosphates and
organic acids).
❏ Inspect nuts and bolts on chassis
2
❏ Lubricate drive shaft, re-torque
bolts (GX 470, LX 470)
❏ Repack front wheel bearings
(LX 470)
❏ Replace air conditioner filter
❏ Replace differential oil
(GX 470, LX 470)
2
❏ Replace rear differential oil
(RX 330 AWD)
2
❏ Replace transfer case oil
(GX 470, LX 470, RX 330 AWD)
2
❏ Road-test vehicle
____Fuel lines and connections, fuel
tank band and fuel tank vapor
vent system hoses
____Fuel tank cap gasket
____Rack and pinion assembly
____Rear differential oil (RX 330 AWD)
____Steering linkage and boots
____Transfer case oil
____Transmission fluid (RX 330)
____Variable gear ratio steering assembly
(LX 470)
Date: _____________________ Mileage: _______________________
Notes:
To Next Page
Loading...
