27 Troubleshooting
27 TROUBLESHOOTING
Troubleshooting Table
Possible Cause Solution
Engine Doesn't Turn Over
Low battery voltage Recharge the battery
Loose batteryconnections Check battery connections, clean and tighten
Loose starter solenoid con-
nection
Check starter connections, clean and tighten
Loose fuse box connections or
blown fuse
Remove, inspect and reinstall related fuses
Engine Turns Over, Fails to Start
Out offuel Refuel
Clogged fuel filter/water sep-
arator
Drain water separator, inspect and/or replace fuel fil-
ter
Clogged air filter Inspect and/or replace air filter
Water is present in fuel Drain the fuelsystem and refuel, replace fuel fil-
ter/water separator
Old or non-recommended fuel Replace with fresh recommended fuel
Water or fuelin crankcase See your localROXOR dealer for assistance
Low battery voltage Recharge the battery
Mechanicalfailure See your localROXOR dealer for assistance
Troubleshooting Table
Possible Cause Solution
Defective fuel pump Inspect and/or replace
Engine Runs Irregularly, Stalls or Misfires
Poor or incorrect fuel Replace with recommended fuel
Low fuel level Refuel
Clogged fuel filter Inspect and/or replace fuel filter
Clogged air filter Inspect and/or replace air filter
Water present in fuel Drain water separator, inspect and/or replace fuelfil-
ter
Kinked or plugged fuel tank
vent line
Inspect and/or replace
Other mechanical failure See your local ROXOR dealer for assistance
Engine Stops or Loses Power
Poor or incorrect fuel Replace with recommended fuel
Air leak in system after tur-
bocharger
Inspect for leaks and repair as required
Boost pressure sensor stuck
open
Check sensor condition and repair or replace
Clogged fuel filter Inspect and/or replace fuel filter
Clogged air filter Inspect and/or replace air filter
© 2018 Mahindra Vehicle Sales and Service, Inc. All Rights Reserved. 79
To Next Page
Loading...
Need help?
General
