Clean and sanitize ice dispenser (continued)
©McDonald’s Corporation · Planned Maintenance Manual · Revised January 2011 Page 4 of 4
Manitowoc Ice, Inc. Ice Machine Models S, IB, and Q
Monthly BE 13 M1
22
Pre-mix Sanitizer
Use 1 liter of warm water.
Add the correct number of
Sanitizer packets to the water.
For models S300, S320,
S420, Q280, Q320 & Q420 –
1 packet
S1200, S1400, S1600, S1800,
Q1300, Q1600 & Q1800 –
3 packets
For all other models –
2 packets
Sanitizer
23
Move ICE/OFF/CLEAN toggle
switch to the CLEAN position.
The clean light will turn on to
indicate the machine is in the
clean mode
24
Sanitize evaporator and water
trough.
Wait for approximately 2
minutes until water starts to
flow over the evaporator, then
pour the pre-mixed solution
into the water trough.
25
Move ICE/OFF/CLEAN toggle
switch to the ICE position.
The ice machine will auto-
matically run through a wash
cycle and several rinse cycles.
The entire cycle lasts approx-
imately 30 minutes. Ice
making will resume automati-
cally when the sanitize cycle
is complete.
26
Reinstall front panels and
tighten screws.
27
Make and discard three loads
of ice.
Discard the first three loads of
ice made.
To Previous Page
Loading...
Need help?
General
