headline barsheadline bars
model no. 055-0216-8 | contact us 1 800 689-9928
54
TROUBLESHOOTING
TROUBLESHOOTING
Problem Possible Causes Solution
Engine will not
start.
No fuel Add fuel.
Faulty spark plug Clean and adjust spark plug or replace.
Low oil level Fill crankcase to the proper level.
Place generator on a flat, level surface.
Spark plug wire loose Attach wire to spark plug.
Fuel valve is closed. Open fuel valve.
Engine switch/Ignition switch/
Power button OFF
Press engine switch/ignition switch/
power button ON.
Old fuel or water in fuel Drain fuel and replace with fresh fuel.
Flooded with fuel Let unit stand for 10 mins.
Engine starts but
runs roughly.
Choke in the wrong position Move choke until it stops under RUN
position or push in completely.
Dirty air filter Clean or replace air filter.
Dirty fuel valve Clean the fuel valve.
Clogged spark arrestor Clean spark arrestor.
Engine shuts down
during operation.
Out of fuel Fill fuel tank.
Low oil level Fill crankcase to the proper level. Place
generator on a flat, level surface.
Clogged spark arrestor Clean spark arrestor.
Generator
cannot supply
enough power or
overheating.
Generator is overloaded. Review load and adjust. See “Do not
Overload Generator” (page 29).
Dirty air filter Clean or replace air filter.
Choke in wrong position Move choke until it stops under RUN
position or push in completely.
To Next Page
Loading...
Need help?
General
