MerCruiser Axius 350 - User Manual

© 2011 Mercury Marine Axius & Axius SeaCore 350, 377 Models with Emissions Control
*8M0053363*
90-8M0053363 1110
NOTE: The following applies to CE marked products only.
Declaration of Conformance – Mercury MerCruiser
This sterndrive or inboard engine when installed in accordance to Mercury MerCruisers’ instructions complies with the
requirements of the following directives by meeting the associated standards, as amended:
Recreational Craft Directive 94/25/EC; 2003/44/EC
Applicable Requirement Standards Applied
Owner’s manual (A.2.5) ISO 10240
Openings in Hull, Deck and superstructure (A.3.4) ISO 9093‑1; ISO 9093‑2
Handling characteristics (A.4) ISO 8665
Inboard Engine (A.5.1.1) ISO 15584; ISO 10088; ISO 7840; ISO 10133
Fuel System (A.5.2) ISO 10088; ISO 7840; ISO 8469
Electrical System (A.5.3) ISO 10133; ISO 8846
Steering system (A.5.4)
Applicable portions of: ISO 10592, ISO 8848 and ABYC
P‑17
Exhaust emission requirements (B.2) ISO 8178
Owner’s manual (B.4) ISO 8665
Noise emission levels (C.1) ISO 14509
Ignition‑protected equipment (Annex II) ISO 8846; SAE J1171; SAE J1191; SAE J 2031
Mercury MerCruiser declares that our sterndrive or inboard engines without integral exhaust, when installed in a
recreational craft, in accordance with the manufacturers supplied instructions, will meet the exhaust emissions
requirements of the directive mentioned above. This engine must not be put into service until the recreational craft in which
it is to be installed has been declared in conformity, if so required, with the relevant provision of the directive.
Electromagnetic Compatibility Directive 89/336/EC, 92/31/EEC and 93/68/EEC
Generic emission standard EN 50081‑1
Generic immunity standard EN 50082‑1
Vehicles, boats and internal combustion engine driven
devices ‑ Radio disturbance characteristics
SAE J551 (CISPR 12)
Electrostatic discharge testing EN 61000‑6‑2; EN 61000‑4‑2; EN61000‑4‑3
The notified body responsible for surveillance of the quality system under Full Quality Assurance Module H of Directive
2003/44/EC is:
Det Norske Veritas
Norway
Notified Body Number: 0575
This declaration is issued under the sole responsibility of Mercury Marine and Mercury MerCruiser.
Kevin Grodzki
President ‑ Mercury MerCruiser, Stillwater, OK, USA
Regulatory contact:
Regulations and Product Safety Department
Mercury Marine
W6250 W. Pioneer Road
Fond du Lac, WI 54936
USA
Identification Record
Please record the following information:

Summary

Declaration of Conformance

Recreational Craft Directive Compliance

Details compliance with Recreational Craft Directive standards.

Electromagnetic Compatibility Directive Compliance

Details compliance with EMC directive standards.

Features and Controls

Safety Features: Lanyard and Emergency Stop

Explains the function of safety switches for engine shutdown.

Operator Controls: Joystick and Remote

Describes operation of joystick and ERC for boat maneuvering.

Instrumentation and Displays

Overview of gauges, VesselView, and digital displays.

Section 4 - Specifications

Fuel and Oil Specifications

Details on required fuel types, octane ratings, and engine oil.

Section 5 - Maintenance

Maintenance Schedule and Responsibilities

Guidelines for routine and scheduled maintenance tasks.

Engine and Fuel System Maintenance

Procedures for servicing engine oil, fuel filters, and systems.

Corrosion Protection and Sterndrive Care

Methods to prevent corrosion and maintain sterndrive components.

Cooling System Flushing Procedures

Steps for flushing the engine cooling system with fresh water.

Section 7 - Troubleshooting

Common Starting Issues

Solutions for engine crank or start failures.

Engine Performance and Overheating Issues

Troubleshooting for poor performance, rough running, or overheating.

Steering and Power Trim Problems

Diagnosing and resolving issues with steering and power trim systems.

MerCruiser Axius 350 Specifications

General

Brand	MerCruiser
Model	Axius 350
Category	Engine
Language	English