Miele T 15xx - Figure 3-2: Positioning the Heater Exchanger Levers; Figure 3-1: Opening the Heat Exchanger Cover

42 pages

To Next Page

To Previous Page

Technical Information!

$=!

T 15xx Dryers

Figure 3-1: 1-'/&/C!7Y'!\'.7!O]0Y./C'3!<92'3!

>,! P'D92'!7Y'!092'3,!!

G,! ?M3/!S97Y!('2'3:!9/!7Y'!Y'.7!']0Y./C'3!:9!7Y.7!7Y'L!.3'!2'37&0.(!@:''!X&CM3'!>A"E,!!

Figure 3-2: R9:&7&9/&/C!7Y'!\'.7'3!O]0Y./C'3!K'2'3:

;,! RM((!9M7!7Y'!Y'.7!']0Y./C'3,!*''!X&CM3'!>A>,!

Main Page

Table of Contents2
Appliance Overview &#X96;- Vented Models5
Figure 1-1: Typical Vented 5K Model5
Construction and Design5
Appliance Overview &#X96;- Condenser Models6
Controls Overview6
T 1515 (5-Kilogram Vented)6
Figure 1-2: Typical Condenser Model Installed Next to Washer6
Figure 1-3: T 1515 Controls6
Figure 1-5: T 1526 Controls7
Figure 1-7: T 1570 C Controls7
Figure 1-6: T 1565 C Controls7
Figure 1-4: T 1520 Controls7
T 1526 (6-Kilogram Vented)7
T 1520 (5-Kilogram Vented)7
Appliance Dimensions8
5-Kilogram Vented Models8
Figure 1-8: T 1576 Controls8
Figure 1-9: Dimensions, 5-Kilogram Vented Models8
T 15768
5-Kilogram Condenser Models9
6-Kilogram Vented Models9
Figure 1-10: Dimensions, 5-Kilogram Condenser Models9
Figure 1-11: Dimensions, 6-Kilogram Vented Models9
Component Layouts10
T 1515, T 1520, T 1526, T 1565 C, T 1570 C10
Figure 1-12: Component Layout (All Models Except T 1576)10
Figure 1-13: T 1576 Component Layout11
T 157611
Electrical Requirements12
Plumbing Information &#X96;- Condenser Models12
Installation12
Installation Procedure13
General Operation: T 1515, T 1520, T 1526, T 1565 C, T 1570 C14
Additional Function Pushbuttons: T 1515, T 1520 T 1526, T 1565 C, T 1570 C14
General Operation &#X96;- T 157614
Commission and Operation14
Program Option Buttons &#X96;- T 157615
Condensed-Water Drawer (Condenser Models Only)15
Heat Exchanger (Condenser Models Only)15
Figure 3-2: Positioning the Heater Exchanger Levers16
Figure 3-1: Opening the Heat Exchanger Cover16
Figure 3-3: Removing the Heat Exchanger17
Figure 3-4: Cleaning the Heat Exchanger17
Vented Dryer &#X96;- Principle of Operation18
Figure 4-1: Vented Dryer Airflow18
Description of Function18
Condenser Dryer &#X96;- Principle of Operation19
Figure 4-2: Condenser Dryer Airflow19
Fan Motor (M5) Assembly20
Figure 4-3: Fan Motor Assembly20
Residual Moisture Setting21
Figure 4-4: Drum Drive Belts and Reduction Pulley21
Temperature Monitoring22
T 1515, T 1520, T 1526, T 1565 C and T 1570 C22
Figure 4-6: Heater Circuit23
Figure 4-5: Heater Bank Assembly (T 1576 Shown)23
Heater Bank Assembly23
Control (Upper) Electronic24
Power (Lower) Electronic24
Electronics Locations by Model Number24
T 1515, T 1520, T 1526, T 1565 C and T 1570 C24
Figure 4-7: Electronics Locations (T 1515, T 1520, T 1526, T 1565 C, T 1570 C)24
Figure 4-8: Electronics Locations on T 157625
Lid Removal26
Figure 5-1: Lid Removal and Front Panel Access26
Service and Maintenance26
Figure 5-2: Removing the Left Section of the Fascia Panel27
T 1515, T 1520, T 1526, T 1565 C and T 1570 C27
Power Electronic Removal27
Front Panel Opening, Vented Models27
Front Panel Opening, Condenser Models27
Figure 5-3: Screw Securing Power Electronic28
Figure 5-4: Removing the Power Electronic on the T 1576 Dryer28
Control Electronic Removal29
T 1515, T 1520, T 1526, T 1565 C and T 1570 C29
Heater Relay Access29
Figure 5-5: Control Electronic Removal: T 1515, T 1520, T 1526, T 1565 C, T 1570 C29
Figure 5-6: Heater Relay Bracket29
Drum Rear Panel Removal30
Figure 5-7: Drum Positioned with the Two Largest Holes Horizontal30
Heater Bank Access31
Figure 5-8: Heater Bank Cover Retaining Bolts31
Figure 5-9: Heater Bank Removal31
Figure 5-11: Fan Motor Bolts32
Figure 5-10: Vent Ring Assembly32
Fan Motor Removal32
Condenser Assembly Removal33
Condenser Fan Removal33
Figure 5-12: Bottom Cover Screws33
Residual Moisture Sensor Removal34
Figure 5-13: Condenser Fan Screws34
Figure 5-14: Residual Moisture Sensor and Screw34
Drum Drive Belt35
Figure 5-15: Positioning the Drum to Form a Gap35
Fault Diagnosis36
Service Mode36
T 1515, T 1520, T 1526, T 1565 C and T 1570 C36
Table 6-1: Service Mode Functions (T 1515, T 1520, T 1526, T 1565 C, T 1570 C)36
Table 6-2: Service Mode Functions (T 1576)37
Fault Codes (T 1576 Only)37
Programming Mode (T 1576 Only)38
Table 6-3: T 1576 Fault Codes38
Residual Moisture Sensor Circuit Test39
T 1515, T 1520, T 1526, T 1565 C and T 1570 C Procedure39
Table 6-4: T 1576 Programming Settings39
T 1576 Procedure40
Dryer Takes too Long to Dry Clothes41
Residual Moisture Sensing Inoperative41
Dryer Door Keeps Popping Open (All Models Except T 1576)41
Water Leaks in Condenser Dryer42
Light, Repetitive Clicking about Every Second While Drum Is Turning42
T 1576 Dryer Shuts down after Less than One Minute of Operation42
Rumbling Sound During Operation42

Miele T 15xx - Figure 3-2: Positioning the Heater Exchanger Levers; Figure 3-1: Opening the Heat Exchanger Cover

Table of Contents

Related product manuals