Moog Satellite Service Manual

How to Order Service Parts
Service parts are stocked only at our Customer Service Department in Sepulveda, California. Please order all
your requirements from:
THOMAS ORGAN COMPANY
CUSTOMER SERVICE DEPARTMENT
8345 HAYVENHURST AVENUE
SEPULVEDA, CALIFORNIA 91343
A. Use your own order form, letter, or postcard.
B. Place your order on our Customer Service Department Electronic
Secretary in the evening (dial Area Code 213, telephone number
893-4416) or - -
C. In case of extreme rush, call the Customer Service Department
during the day at Area Code 213, telephone number 894-7161 and
ask for extension 356 or 357.
Parts List
SATELLITE P.C. BOARD ASSEMBLY
SATELLITE CONTROL P.C. BOARD ASSEMBLY
SCHEMATIC
PART
SCHEMATIC PART
LOCATION
NUMBER DESCRIPTION
LOCATION NUMBER DESCRIPTION
C2,C3 18-5217-3 220uF, 25V (Electro)
Cl ,C2
18-5217-3 220uF, 25V. (Electro)
C4 18-5214-3 1,5uF, 20V (Tantalum)
D1.D2.D3.D4
86-5045-3 Diode, Silicon (Power
C15-.C25
18-5215-3 2,2uF, 50V (Electro) IN4004)
C31
18-5216-3 220uF, 6,4V (Electrol D5 86-5044-3
Diode, Silicon(Signal
D1 thru D12 86-5044-3
Diode, Silicon(Signal 1N 4148)
IN4148)
R7.R8.R9 24-5350-0
100K, Pot Slide, (Linear)
R1.R47.R98, 1
R10.R12 24-5352-0
500K, Pot Slide, (Log)
R103.R139.R174.)
• 24-5340-3
100K Ohm. Trim Pot R11.R13
24-5351-0
100K, Pot Slide, (Log)
R190 J
T1 80-5008-0
Transformer, Power
R4 24-5335-3 500 Ohm, Trim Pot
IC1.IC2
13-5018-6
Intergrated Circuit,
R10 24-5338-3 2 OK Ohm, Trim Pot
(OP-Amp. 741)
R16.R21
24-5337-3 10K Ohm. Trim Pot
01 86-5148-2
Transistor. NPN (2N3904)
R17.R79
24-5342-3 100 Ohm. Trim Pot
35-36000-0
Satellite Control, P.C.
R25
24-5341 -3
2 Meg. Ohm, Trim Pot Bd. Assy.
R130.R132 24-5339-3
2K Ohm, Trim Pot
R160 24-5336-3
1 K Ohm, Trim Pot
MISCELLANEOUS CABINET PARTS LIST
R6.R7 61-100201-2
10K Ohm. 1/4W, 1% Film
11-5837-0
Panel, Rear Controls
R9
R13.R19.R48
R18
R20
R80
R81.R82
61-442301-2
61-150301-2
61-681001-2
61-475201-2
61-174101-2
61-511201-2
442K Ohm, 1/4W. 1% Film
150K Ohm. 1/4W, 1% Film
681 Ohm, 1/4W. 1% Film
47.5K Ohm. 1/4W, 1% Film
1.74K Ohm. 1/4W, 1% Film
51.IK Ohm. 1/4W, 1% Film
R114 61-5000-1
1 K Ohm, 3% Temp. Comp. J2
IC1 13-5020-6
Intergrated Circuit,
J3
(Voltage Reg. 723)
J4
IC2,IC3,IC4, *
1
R238
IC5.IC6.IC7.
IC8.IC13.IC21,
IC22
7 13-5018-6
Intergrated Circuit,
(OP-Amp. 741)
R237
IC9.IC10.IC12,
IC14,IC15,IC16,
113-5019-6
Intergrated Circuit,
1 Cl 7,1 Cl 8
(OP-Amp. CA-3080)
1 Cl 1,1 C19.IC20 13-5015-6
Intergrated Circuit.
(Transistor Array SG-3821)
IC23 13-5074-3
Resistor Matrix
Q1
Q2.Q4.Q6.Q7,
Q9.Q10.Q11,
012,013.014,
86-5150-2 Transistor, (PNP TIS93)
Q15,Q17,Q25,
Q26.Q27.Q31,
•86-5149-2
Transistor, (PNP 2N3906)
034,035,036,
Q43.Q44.Q46,
Q47,Q48.Q50 .
03,05,08,016, '
Q18,Q19,Q21.
Q24.Q28. Q29,
030,033,037,
Q38,Q39.Q40.
Q49
■ 86-5148-2
Transistor, (NPN 2N3904)
Q20,Q32,Q41,
Q42.Q51 J
f 86-5147-2
Transistor, (FET, N-CHAN.
E203)
Q22.Q23
86-5146-2 Transistor, (FET. N-CHAN.
El 12)
45-5049-0
Connector, 12-Pin Male
Polar
45-5043-5 Terminal. 1C, 4-Pin Socket
45-5044-5
Terminal, 1C, 7-Pin Socket
45-5022-2
Socket, 1C,8-Pin Circular
77-5129-0 Spacer, 1C, Socket, 7-Line
35-35990-0 Satellite, P.C. Bd. Assy.
SW1 thru SW21
J1
40-5133-0
40-5134-0
69-5367-0
89-5083-0
21- 5355-1
45-5022-1
45-5023-1
45-5076-3
45-5024-1
24-5353-0
24-5354-0
52-5220-0
52-5221-0
77-5130-0
49-5330-0
49-5331-0
23-5017-0
22- 5023-0
23- 5051-1
23-5053-1
62-8268-1
62-8269-1
62-8270-1
62-8271-1
62-8272-1
62-8273-1
62-8274-1
62-8275-1
62-8276-1
62-8277-1
62-8278-1
62-8279-1
62-8280-1
62-8281-1
62-8282-1
1 1-5847-0
11-5848-0
26-5004-0
70-5201-0
97-5351-0
70-5202-0
Overlay. Slider Panel
Overlay, Front Controls
Switch, with Quick-Tab
Lamp. Pilot with Clip
Housing, 24-Pin Female
Socket. 6-Pin (Accessory!
Jack, Phone
Jack, RCA-Phono
Jack. Phone (Shorting Type)
5OK Ohm, Pot Rotary (Level)
100K Ohm, Pot Rotary (Tune)
Knob, Rotary (Push-on)
Knob, Slide Pot
Standoff, P.C. Bd. Mounting
Foot, Rubber
Foot, Adjustable
Cord. A.C. Power
Strain Relief
Cable. Output Accessory
Adapter. "Y"
"A" Key Natural (Ivory)
"B" Key Natural (Ivory)
"C" Key Natural (Ivory)
"D" Key Natural (Ivoryj
"E" Key Natural (Ivory)
“F" Key Natural (Ivory)
"G" Key Natural (Ivory)
"C" End Key Natural (Ivory)
"A" Key Natural (Black)
"B" Key Natural (Black)
"C" Key Natural (Black)
”D" Key Natural (Black)
"E" Key Natural (Black)
"F" Key Natural (Black)
"G" Key Natural (Black)
62-8283-1 Sharp Black
Channel, Natural
Channel. Sharp
Bushing, Guide
Spring, Key Return
Screw, Key
Spring, Contact

Moog Satellite Specifications

General

Brand	Moog
Model	Satellite
Category	Synthesizer
Language	English