Motorola GP360 Service Information

2-4 TROUBLESHOOTING CHARTS
4.0 Lowband Controller
MCU Check
Power Up
Alert Tone
OK?
Speaker
OK?
U409 EXTAL=
7.3728 MHz?
U205 Pin 19
17.0MHz
5V at U204?
3.3V at
U400?
U409 Reset
Pin 94
High?
MCU is OK
Not able to pro-
gram RF Board
ICs
Before replacing
MCU, check SPI
clock, SPI data,
and RF IC select
Replace
Speaker
Read Radio
OK?
Check
Setup
Reprogram the
correct data.
See FGU
Troubleshooting
7.5V at
Pin 5 U204?
7.5V at Pin 8
U400
Check
Q400
Replace
U204/U400
Check any short
to SWB+,
Vdda or Vddd
Press PTT. Red
LED does not
light up
PTT U409
Pin 53
low?
Press PTT
CR502-2
High?
Check
PB504
Check
CR502-2
voltage
LED,
CR502,R501
OK?
Replace
Faulty
Component
Check
Accessories
J403
OPT_SEL_1 &
OPT_SEL_2
Pin 8 & 9
low?
Radio could
not PTT
externally
U409
Pin 52, 6
low?
See FGU
Troubleshoot-
ing chart
LED should
light up
Check
MCU
PTT
NO
YES
YES
No
NO
YES
YES
NO
YES
YES
NO
NO
YES
YES
NO
NO
YES
NO
YES
NO
YES
YES
NO
NO
YES
EXT
SPKR
EXT
PTT
INT
AUDIO
J403 Pin 9
low? Pin 8
high?
ASFIC U404
Pin 14 & 15
high?
Check
Accessories
Check
U404
Check
U420 Audio PA
NO
NO
YES
YES
J403 Audio
at Pin 2 &
Pin 3
Check Spk. Flex
Connection
Audio at
AudioPA
(U420)
input
Audio from Pin 41
ASFIC, U404?
Check
ASFIC U404
Check
Audio PA
(U420)
Check
U303
LV ZIF
Audio at
Pin 2
U404?
NO
NO
NO
YES
YES
NO
YES
NO

Motorola GP360 Specifications

Battery

battery life with standard high capacity NiMH battery low power	11 hours
battery life with standard high capacity NiMH battery high power	8 hours
battery life with ultra high capacity NiMH battery low power	14 hours
battery life with ultra high capacity NiMH battery high power	11 hours
battery life with NiCD battery low power	12 hours
battery life with NiCD battery high power	9 hours
battery life with Li-lon low power	11 hours
battery life with Li-lon high power	8 hours

Operating Environment

operating temperature	-20°C to +55°C
sealing	Withstands rain testing per MIL STD 810 C/D/E and IP54
shock and vibration	Protection via impact resistant housing exceeding MIL STD 810-C/D/E and TIA/EIA 603
dust and humidity	Protection via environment resistant housing exceeding MIL STD 810 C/D/E and TIA/EIA 603

Transmitter Specifications

frequencies full bandsplit VHF	136-174 MHz
frequencies full bandsplit UHF	403-470 MHz
channel spacing	12.5/20/25 kHz
frequency stability	±2.5 ppm
power VHF	1-5W
power UHF	1-4W

Receiver Specifications

frequencies full bandsplit VHF	136-174 MHz
frequencies full bandsplit UHF	403-470 MHz
channel spacing	12.5/20/25 kHz
frequency stability	±2.5 ppm
sensitivity (12 dB SINAD) EIA	0.25 µV typical
sensitivity (20 dB SINAD) EN	0.50 µV typical

Weight and Dimensions

dimensions with standard high capacity NiMH battery	137 x 57.5 x 37.5 mm
dimensions with ultra high capacity NiMH battery	137 x 57.5 x 40.0 mm
dimensions with NiCD battery	137 x 57.5 x 40.0 mm
dimensions with Li-lon battery	137 x 57.5 x 33.0 mm
weight with standard high capacity NiMH battery	428 gm
weight with ultra high capacity NiMH battery	508 gm
weight with NiCD battery	458 gm
weight with Li-lon battery	358 gm