EasyManua.ls Logo

MTD 807 - User Manual

MTD 807
48 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
PRINTED IN U.S.A.
FORM NO.
770-10354B.fm
(12/2001)
Automatic Garden Tractor
Models 807
808
OPERATOR’S MANUAL
Model B807K Shown
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered,
brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or
state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California
the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws
apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the
service department, P.O. Box 361131 Cleveland, Ohio 44136-0019.
MTD LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019

Table of Contents

Questions and Answers

  • J
    john67Jul 26, 2025
    Why MTD 807 engine fails to start?
    • M
      Misty ChavezJul 26, 2025
      To resolve the issue of your MTD Lawn Mower engine failing to start: Ensure the PTO knob (or lever) is disengaged (OFF) and the parking brake is engaged. Connect the wire(s) to the spark plug(s) and set the throttle lever to the FAST position. Pull out the CHOKE control (if equipped) or place the throttle control in the CHOKE position. Fill the tank with clean, fresh gas (less than 30 days old). Clean the fuel line or replace the fuel filter, if equipped. Clean, adjust the gap, or replace the spark plug. Finally, crank the engine with the throttle in the FAST position.
  • L
    Laura BautistaJul 31, 2025
    What to do if MTD 807 engine runs erratic?
    • M
      mcclainjamesJul 31, 2025
      If your MTD Lawn Mower engine is running erratically: Push the CHOKE control in (if equipped) or move the throttle control out of the CHOKE position. Connect and tighten the spark plug wire(s). Clean the fuel line and fill the tank with clean, fresh gasoline (less than 30 days old). Replace the fuel filter, if equipped. Clear the vent or replace the cap if damaged. Drain the fuel tank and refill it with clean, fresh gasoline (less than 30 days old). Replace the air cleaner cartridge/element or clean the pre-cleaner, if equipped.
  • J
    Joanna ReevesAug 4, 2025
    What to do if MTD Lawn Mower engine overheats?
    • S
      sharon85Aug 4, 2025
      If your MTD Lawn Mower engine overheats, ensure the crankcase is filled with the proper capacity and weight of oil. Also, clean any grass clippings and debris from around the engine’s cooling fins and blower housing.
  • S
    shawmichelleAug 9, 2025
    How to fix excessive vibration in MTD Lawn Mower?
    • B
      Brent GuzmanAug 9, 2025
      To address excessive vibration in your MTD Lawn Mower: * Tighten the blade and spindle. * Balance the blade. * If necessary, replace the blade.
  • R
    Robert ClarkAug 12, 2025
    Why MTD Lawn Mower idles poorly?
    • J
      Jennifer CarpenterAug 13, 2025
      If your MTD Lawn Mower idles poorly, try the following: * Replace the spark plug(s). * Set the spark plug(s) gap. * Replace the air cleaner cartridge/element or clean the pre-cleaner, if equipped.
  • P
    Pamela LindseyAug 17, 2025
    Why MTD Lawn Mower will not mulch grass?
    • T
      turnerjeffreyAug 17, 2025
      If your MTD Lawn Mower isn't mulching grass effectively (if equipped): Place the throttle control in the FAST position. Avoid mowing when the grass is wet; wait until it's drier. Mow once at a high cutting height, then mow again at the desired height, or make a narrower cutting swath. Sharpen or replace the blade.
  • J
    Jason ChapmanAug 21, 2025
    What to do if MTD 807 Lawn Mower has uneven cut?
    • D
      danielstephensAug 22, 2025
      To correct an uneven cut with your MTD Lawn Mower: * Perform a side-to-side deck adjustment. * Sharpen or replace the blade. * Check the tire pressure in all four tires.

Summary

Safety Guidelines

General Operation Safety

Essential guidelines for safe operation and understanding controls.

Slope Operation Safety

Precautions and procedures for safe operation on slopes.

Children Safety

Warnings and guidelines to protect children from hazards.

Tractor Setup

Battery and Fluid Setup

Steps for battery connection and filling fluids.

Shipping Brace Removal

Instructions for removing the shipping brace before operation.

Know Your Tractor Controls

Control Panel Overview

Identification and function of tractor controls and indicators.

Key Operating Controls

Operation of throttle, choke, ignition, drive, brake, and parking controls.

PTO, Seat, and Deck Controls

How to engage PTO, adjust seat, and use deck lift lever.

Operating Your Tractor

Safety Interlock System

Explanation of safety interlock system preventing unintended starting.

Starting and Stopping the Engine

Procedures for safely starting and stopping the tractor engine.

Driving and Mowing

Guidelines for driving, parking, and mowing safely.

Adjustments

Brake and Seat Adjustment

Procedures for adjusting parking brake and operator seat.

Steering and Deck Adjustment

Procedures for adjusting steering alignment and deck height/level.

Maintenance

Engine Maintenance

Routine engine care, including oil changes and air filter service.

Lubrication and Cleaning

Lubricating key points and cleaning the tractor.

Service

Cutting Deck and Belt Service

Procedures for deck removal and changing belts.

Blade and Tire Service

Procedures for servicing cutting blades and tire inflation.

Battery and Charging

Information on battery maintenance and charging procedures.

Troubleshooting

Engine Troubleshooting

Solutions for engine starting, running, and overheating problems.

Mowing Troubleshooting

Solutions for problems like uneven cuts or mulching failures.

Attachments & Accessories

Compatible Attachments

List of accessories compatible with tractor models.

Parts List

Model Parts Identification

Diagram and list identifying tractor components and part numbers.

MTD 807 Specifications

General IconGeneral
BrandMTD
Model807
CategoryLawn Mower
LanguageEnglish

Related product manuals