Napoleon BGD40-N - Table of Contents

2
W415-0811 / D / 08.16.12
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.1.1 PENINSULA 5
2.1.2 OPEN-END 5
2.1.3 SEE-THRU 5
2.2 GENERAL INSTRUCTIONS 6
2.3 GENERAL INFORMATION 7
2.4 RATING PLATE INFORMATION 7
3.0 VENTING 8
3.1 VENTING LENGTHS AND COMPONENTS 9
3.2 TYPICAL VENT INSTALLATIONS 10
3.3 SPECIAL VENT INSTALLATIONS 11
3.3.1 PERISCOPE TERMINATION 11
3.4 VENT TERMINAL CLEARANCES 12
3.5 VENT APPLICATION FLOW CHART 13
3.6 DEFINITIONS 13
3.7 ELBOW VENT LENGTH VALUES 13
3.8 HORIZONTAL TERMINATION 14
3.9 VERTICAL TERMINATION 16
4.0 PENINSULA INSTALLATION 18
4.1 VENTING 18
4.2 FRAMING 18
4.3 COUNTER TOP / BAR INSTALLATION 19
4.4 BRICK PANEL INSTALLATION 20
4.5 FACING 20
4.6 FINISHING 20
5.0 OPEN-END INSTALLATION 21
5.1 VENTING 21
5.2 FRAMING 21
5.3 BRICK PANEL INSTALLATION 22
5.4 FACING 22
5.5 FINISHING 22
6.0 SEE-THRU INSTALLATION 23
6.1 VENTING 23
6.2 FRAMING 23
6.3 BRICK PANEL INSTALLATION 24
6.4 FACING 24
6.5 FINISHING 24
7.0 FRAMING 25
7.1 MINIMUM CLEARANCE TO COMBUSTIBLES 25
7.2 MINIMUM CLEARANCE TO COMBUSTIBLE ENCLOSURES 25
7.3 ALCOVE INSTALLATION 26
7.4 MINIMUM MANTEL CLEARANCES 27
8.0 INSTALLATION 28
8.1 WALL AND CEILING PROTECTION 28
8.1.1 HORIZONTAL INSTALLATION 29
8.1.2 VERTICAL INSTALLATION 30
8.2 USING FLEXIBLE VENT COMPONENTS 30
8.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 31
8.2.2 VERTICAL AIR TERMINAL INSTALLATION 32
8.2.3 APPLIANCE VENT CONNECTION 33
8.3 GAS INSTALLATION 33
8.4 OPTIONAL WALL SWITCH INSTALLATION 34
9.0 FINISHING 35
9.1 DOOR INSTALLATION 35
9.2 END DOOR INSTALLATION 35
9.3 HEAT SHIELD STAND-OFF REMOVAL (SEE-THRU INSTALLATION ONLY) 36
9.4 LOUVRE INSTALLATION 36
9.5 LOG PLACEMENT 37
9.6 CHARCOAL EMBERS 38
9.7 LOGO PLACEMENT 38
10.0 OPTIONAL BLOWER INSTALLATION 39
11.0 OPERATION 40
12.0 ADJUSTMENTS 41
12.1 PILOT BURNER ADJUSTMENT 41
12.2 VENTURI ADJUSTMENT 41
12.3 FLAME CHARACTERISTICS 42
12.4 RESTRICTING VERTICAL VENTS 42
13.0 MAINTENANCE 43
13.1 CARE OF GLASS 43
14.0 REPLACEMENTS 44
15.0 TROUBLESHOOTING 48
16.0 WARRANTY 51