Nupower EVOLUTION NPECH250 - SPECIFIC SAFETY RULES

15
GB
SPECIFIC SAFETY RULES
Pleasereadtheoperatinginstructionscarefullybeforeyou
mount thedevice and use it forthe first time, andkeep
theminasafeplaceforfuturereference.
Warning!
The electric hoist is designed for private household
use only! It is not designed for continuous use in
professional operations.
During the use of the appliance make use of the proper
protection tools like gloves, glasses, crash helmet,
safety shoes, etc. according to the regulations in force.
Warning!
Before using this electric product, carefully read the
safety rules listed below.
• Yoursocketplugmustabsolutelybegroundedandyour
 electricsystemmustbesuppliedwithamagnetocut-out
 safety.
• Protectthemachinefromfrostandlowtemperatures.
• In casethe machinecannot hoista load,do not keep
 pressingthehoistingpush-button:thismeansthattheload
 exceedsthemachinemaximumcapacity.
• Themachineshallnotbedisassembledwhenrunningor
 connectedtopower.
• Donotstandunderhoistedweights.
• Beforestartingthework,makesurethatthesteelcableis
 correctlywindedaroundthereel.
• OBSERVE THE MAXIMUM LOAD INDICATED ON THE
HOIST, NOT THAT ON THE HOOK!
• Toavoidanydanger,donotwindmorethan15mtofcable
 aroundthereel.
• Incasethesteelcableiswornout,itmustbereplacedonly
 withacableofsamefeaturesmanufacturedbyus.Ifcanbe
 foundatallauthorizedserviceshops.
• Beforestartingthework,checkthatswitchesareingood
 operatingconditions.
• Incasethehoiststopsduringtheloweringofaload,it
 isnormalthattheloadgoesdownafewcentimetersmore
 becauseofinertia.
• Donotletthecableunwindsofarthatitstartstowind
 up againin reverse.This will cause the cableto kink.
 The windingandunwindingdirectionswill reverse, the
limit switch will not function and the cable will kink as
 result.Theremustbeatleastthreerevolutionsofcable
 leftonthereelatalltimes,sothatthecableconnection
 is not under stress, and whenever-the red end of the
 cable appears you must not unwind any further!
• Theloadmustneverbefasteneddirectlytotheliftingcable.
 Itmustbefastenedtotheliftinghookonly.
• Thehoistoperatormustkeepapermanenteyeonthe
 movementoftheload.Ifthehoistoperatorcannotsee
 theliftingorloweringmovements,thedangerareamust
be sealed off and additional persons with a full view of
 theoperatingareashouldgiveinstructions.
The hoist operator must always be able to see the end of
 theloadpath,otherwisetheemergencylimitswitchwillbe
 actuatedinthecourseofoperations.
If the hoist operator leaves the control position of devices with
 suspended loads, the danger area beneath the load
 mustbemadesecure.
• Hoistsmayonlybeusedforliftingandloweringloads.
• ITISABSOLUTELYFORBIDDENtheuseoftheblockand
 tackleforpeopletransportation.
•DONOTstayundertheload.
•DONOTmoveorliftloadsheavierthenthemaximumload
allowed as indicated on the machine
•DONOTdrawskewloads.
•DONOTchargethehooksonthetip.
•DONOTguidethehangingloadbyhandsbutonlybyropes
 orhooks.
•DONOTusetheropeoftheblockandtacklefortheloads
 harness.
•DONOTtouchtheropeduringtheoperation.
•IT’SABSOLUTELY FORBIDDEN theuse of ad-libbed
 ornotstandardloadshooksorropes.
•DONOTUSEtheblockandtackleincaseofbadweather
 (rain,freezingcold,snow)andinparticularintheeventof
 strongwind.
• Do not use the appliance if it’s not in perfect working
 conditions.