Overhead door RMX DRAWBAR User Manual

FOR ASSISTANCE CALL 1-800-275-6187
Table of Contents
Section 1 How to use this manual......................................1.1
Section 2 Safety Information & Instructions...................2.1
Section 3 General Information.............................................3.1
Section 4 Installation...............................................................4.1-4.9
Drawbar Assembly................................................4.1-4.6
Attach Operator ....................................................4.7
Connection to the Door .....................................4.8
Clutch and Brake Adjustment ..........................4.9
Section 5 Power and Control Wiring .................................5.1-5.7
Line Voltage Wiring..............................................5.1
Low Voltage Control Wiring..............................5.2
External Wire Diagram ........................................5.3
Wall Control.............................................................5.4
Interlock Switches & Radio Control................5.5
Radio Control & Photocell Wiring ...................5.6
Sensing Edge Wiring............................................5.7
Section 6 Operator Setup Procedures ..............................6.1-6.8
Control Panel ..........................................................6.1
Setting Constant Contact ..................................6.2
Setting Limit Travel...............................................6.3
Setting Limit Overrun..........................................6.4
Using Ser
ies II Safe-T-Beam® Photocells ......6.5
Max Run Timer .......................................................6.6
Setting the M
id-Stop...........................................6.7
Changing Open & Close Modes ......................6.8
Section 7 Special Operator Features .................................7.1-7.2
Operator Cycle Count..........................................7.1
Circuit Board Firmware version .......................7.1
Operator Type ........................................................7.2
Section 8 Troubleshooting....................................................8.1-8.4
Display Operation.................................................8.1
Error Codes..............................................................8.1-8.2
Run Codes................................................................8.2-8.3
LED Indicators ........................................................8.4
Section 9 Service & Maintenance .......................................9.1
Section 10 Appendix A .............................................................10.1-10.9
Operator Exploded View ...............................10.1
Operator Parts List...........................................10.2
Shaft Assemblies ..............................................10.3
Shaft Parts List...................................................10.4
Rail/Trolley..........................................................10.5
Rail/Trolley Parts...............................................10.6
Electric Box Exploded View..........................10.7
Electric Box Parts List ......................................10.8-10.9
Appendix B..............................................................10.10
Screw Terminal Assignments.......................10.10
Appendix C..............................................................10.11-10.13
Display Run Codes...........................................10.11
Display Er
ror Codes.........................................10.12-10.13
Appendix D
Safe-T-Beam® Monit
ored Photocell
Troubleshooting Chart ...................................10.14
Section 11 Warranty...................................................................11.1
TOC
07/30/09

Overhead door RMX DRAWBAR Specifications

General

Brand	Overhead door
Model	RMX DRAWBAR
Category	Door Opening System
Language	English