Perkins M300C - Page 4

4 KENR9126
Table of Contents
CID 0262 FMI 04 .................................................. 93
CID 0268 FMI 02 .................................................. 9
3
CID 0342 FMI 08 .................................................. 94
CID 0342 FMI 11 ................................................... 94
CID 0526 FMI 05
.................................................. 94
CID 0526 FMI 06 .................................................. 95
CID 0526 FMI 07 .................................................. 95
CID 0535 FMI 0
3 .................................................. 96
CID 0535 FMI 04 .................................................. 96
CID 0774 FMI 08 .................................................. 96
CID 0774 FMI
13 .................................................. 97
CID 1779 FMI 05 .................................................. 97
CID 1779 FMI 06 .................................................. 97
CID 1785 FMI
03 .................................................. 98
CID 1785 FMI 04 .................................................. 98
CID 1785 FMI 10 .................................................. 98
CID 1797 FM
I 03 .................................................. 99
CID 1797 FMI 04 .................................................. 99
CID 18 34 FMI 02 ................................................ 100
CID 2246 FM
I 05 ................................................ 100
CID 22 46 FMI 06 ................................................ 100
Troubles
hooting w ith an Event Code
Event Codes ...................................................... 102
E096 High Fuel Pre ssure .................................... 104
E113 High
Transmission Oil Pressure ................ 104
E119 Low Fuel Level .......................................... 105
E179 Alternator Not Charging ............................. 105
E194 Hig
h Exhaust Temperature ........................ 105
E198 Low Fuel Pressure .................................... 106
E232 High Fuel/Water Separator Water Level .... 106
E268 Une
xpected Engine Shutdown .................. 107
E360 Low Engine Oil Pressure ....................... .... 107
E361 High Engine Coolant Temperature ............ 108
E362 En
gine Overspeed ..................................... 109
E363 High Fuel Supply Temperature .................. 109
E396 High Fuel Rail Pressure ............................. 110
E398 L
ow Fuel Rail Pressure .............................. 110
E539 High Intake Manifold Air Temperature ........ 111
E877 High Transmission Oil Temperature .......... 112
E1044
High Intake Manifold Pressure ................. 112
E1045 Low Intake Manifold Pressure .................. 112
E2143 Low Engine Coolant Level ........................ 113
Diagnostic Functional Tests
5 Volt Sensor Supply Circuit - Test ...................... 115
CAN D
ata Link Circuit - Test ............................... 122
Coolant Level Sensor Circuit - Test .................... 126
Data Link Circuit - Test ........................................ 131
ECM
Memory - Test ................ ............................ 137
Electrical Connectors - Inspect ........................... 138
Electrical Power Supply Circuit - Test ................. 142
Eng
ine Pressure Sensor Open or Short Circuit -
Test ................................................................... 146
Engine Speed/Timing Sensor Circuit - Test ........ 154
En
gine Temperature Sensor Open or Short Circuit -
Test ................................................................... 159
Engine Temperature Sensor Open or Short Circuit -
Te
st ................................................................... 165
Fuel Lev el - Test ................................................. 170
Fuel Rail Pump Solenoid - Test .......................... 173
I
gnition Keyswitch Circuit and Battery Supply Circuit -
Test ................................................................... 177
Indicator Lamp Circuit - Test ............................... 183
Injector Data I
ncorrect - Test ............................... 186
Injector Solenoid Circuit - Test ............................ 188
Speed Control (PWM) - Test ............................... 196
Starting Aid (
Glow Plug) Relay Circuit - Test ...... 201
Switch Circuits - Test .......................................... 205
Throttle Position Sensor - Test ............................ 207
Transmissio
n Oil Tempe rature - Test .................. 209
Wastegate Solenoid - Test .................................. 212
Index Section
Index ................................................................... 218