Piper CHEROKEE D - Page 59

CHEROKEE"D"
SECTION V
SKETCH G
'
"
•
'
DOOOD.
DAlY 50 1 DD 511 AS
OIL
HAID
........
&lEASE
IIIII
SP'-AY
IIUSH
l!.l!!J[;)OOO~£!\ 'JO@Iro
~ lXI £!\00 1J
IP£!\~~®~~®@ ~liD"
681115
IEQUIIED
01
PACI
CAl
CAl
TYPE OF LUBRICANTS
IDENTIFICATION SPECIFICATION LUBRICANT
LETTER
MIL-L-7870 LUBRICATING OIL, GENERAL PURPOSE,
LOW TEMPERATURE
MIL-L-6082 LUBRICATING OIL, AIRCRAFT RECIPRO-
CATIHG EHGIHE (PISTOH) GRADE AS
SPECIFIED
SAE SO ABOVE 61)oF AIR TEMP.
SAE 40 30• TO 90•F AIR TEMP.
SAE 30 0• TO 70•F AIR TEMP.
SAE 20 BELOW HJ<>F AIR TEMP.
MIL-H-5606 HYDRAULIC FLUID, PETROLEUM BASE
MIL-G-23827 GREASE, AIRCRAFT AND INSTRUMENT,
GEAR AND ACTUATOR SCREW
MIL-G-3545 GREASE, AIRCRAFT, HIGH TEMPERATURE
DUPONT ALL PURPOSE SLIP SPRAY 116611
OR EQUIVALENT
PARKER "0" RING LUBRICANT
SPECIAL INSTRUCTIONS
l. AIR FILTER- TO CLEAN FILTER,'TAP GENTLY TO REMOVE
DIRT PARTICLES. DO NOT BLOW OUT WITH COMPRESSED AIR OR
USE OIL. REPLACE FILTER IF PUNCTURED OR DAMAGED.
2. BEARINGS AND BUSHINGS - CLEAt:\ EXTERIOR WITH A DRY TYPE
SOLVENT BEFORE LUBRICATING.
3. WHEEL BEARINGS- DISASSEMBLE 'AND CLEAN WITH A DRY TYPE
SOLVENT. ASCERTAIN THAT GREASE IS PACKED BETWEEN THE
BEARING ROLLER AND CONE. DO HOT PACK GREASE IN WHEEL
HOUSING:
4. OLEO STRUTS AND BRAKE RESERVOIR - FILL PER
INSTRUCTIONS OH UNIT OR CONTAINER, OR REFER TO SERVICE
MANUAL, SECTIOM II.
5. "0" RING, CONTROL SHAFT BUSHlH~- DISASSEMBLY "0" RING
RETAit_-IER PLATES FROM IHSTRUjjjENT PANEL, LUBRICATE "0"
RING AND REASSEMBLE.
6. LUBRICATION POINTS- WIPE ALL' LUBRICATION POINTS CLEAN
OF OLD GREASE, OIL, DIRT, ETC. BEFORE LUBRICATING.
7. INTERVALS BETWEEN OIL CHANGES CAN BE INCREASED AS
MUCH AS 100% ON ENGINES EQUIPPED WITH FULL FLOW (CAR-
TRIDGE TYPE) OIL FILTERS - PROVIDED THE ELEMENT IS RE-
PLACED EACH 50 HOURS OF OPERATION.
1. PILOT AND PASSENGER SEATS- LUBRICATE TRACK ROLLERS
AND STOP PINS AS REQUIRED. (TYPE OF LUBRICANT: "A")
2. WHEEL BEARINGS REQUIRE CLEANING AND REPACKING AFTER
EXPOSURE TO AN ABNORMAL QUANTITY OF WATER.
3. FUEL SELECTOR VALVE -LUBRICATE FUEL SELECTOR VALVE
AS REQ.!.!.lBf;_D, REFER TO PIPER SERVICI;_LETTER NO. 351.
4. SEE LYCOMING SERVICE INSTRUCTIONS NtJ.lOTif FOR USE OF
DETERGENT OIL.
CAUTIONS
1. DO NOT USE HYDRAULIC FLUID WITH A CASTOR OIL OR ESTER
BASE.
2. DO NOT OVER-LUBRICATE COCKPIT CONTROLS.
3, DO NOT APPLY LUBRICANT TO RUBBER PARTS
42/43