52
ADULT SECTION
Maintenance
Careful periodic maintenance will help keep your vehicle in the safest,
most reliable condition. Inspection, adjustment and lubrication of
important components are explained in the following chart and in the
maintenance section of this manual.
Service and adjustments are critical. If you’re not familiar with safe
service and adjustment procedures, have a qualified dealer perform
these operations.
NOTE: The following chart is a guide based on average riding
conditions. You may need to increase frequency based on riding
conditions. When inspection reveals the need for replacement parts,
we recommend the use of genuine P olaris parts, available from your
Polaris dealer.
ITEM DAILY WEEKLY OR
BEFORE
EXTENDED
PERIOD OF
OPERATION
50
HRS
100
HRS
150
HRS
SEE
PAGE
Check brake operation and
adjustment
X 58 -59
Test engine stop switch
(auxiliary shut-off switch)
X 28
Test throttle safety switch X 27
Test tether switch X 31
Test throttle lever operation X 26
Test brake lever operation X 26
Check steering system
operation
X 26
Check operation of h eadlight
and taillight
X 31
Clean dust and chaff from
engine
X
Check ski skags, replace when
worn to 1/2 original diameter
X 76
Inspect fuel lines, replace if
needed
X 56
Check engine oil level X 62
Oil the drive chain Every10Hrs
Check track tension, tighten if
necessary
Every10Hrs 67
Grease the clutch Every15Hrs 61
Change oil At 2 0 Hrs X X X 62
To Next Page
Loading...
Need help?
General
