90
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
" More often under severe use, such as dirty or wet conditions to
purge water or dirt contamination from grease fittings and other
critical components.
L Emission Control System Service (California - 4-Cycle) NOTE:
Some 4-Cycle models may have an additional California -only
emissions warranty. Please refer to your owner’s manual supplement
to determine if this applies to your vehicle.
Item Hours or
Miles
When Remarks
" Transmission Oil
Level
20 hrs Monthly Inspect monthly; change
annually
Battery 20 hrs Monthly Check Terminals/clean/
check fluid level
Engine Counterbal-
ance
(400 Engines)
20 hrs Monthly Check oil level; change
annually
"
L
Engine breather filter
(4-cycle)
20 hrs Monthly Inspect--replace annually
and as needed
J Brake pad wear 10 hrs Monthly Inspect periodically
" Front and Rear Gear-
case Oil (shaft drive)
100 hrs Monthly Check monthly and
change annually
Engine Cylinder
Head and
Cylinder Base Fas-
teners
25 hrs 3
months
Inspect (re-torque required
at first service only)
" General Lubrication 50 hrs 3
months
Lubricate all fittings, pivots,
cables, etc.
"
L
Engine Oil - Level/
Change (4-Cycle)
100 hrs /
1000
miles
6
months
Check Level Daily; Break
in Service at 1 month.
Change oil more often in
cold weather use.
Due to the nature of the adjustments marked with a J on the
following chart, it is recommended that service be performed by
an authorized Polaris dealer.
CAUTION
To Next Page
Loading...
Need help?
General
