Polaris Ranger 1000 Diesel - Engine Oil

67
MAINTENANCE
Periodic Maintenance Chart
? Perform these procedures more often for vehicles subjected to severe use.
D Have an authorized POLARIS dealer or other qualified person perform these services.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles (Km)
D Throttle pedal 50 H 6 M 500 (800) Inspect for free movement; replace
pedal as needed
Throttle body air intake ducts/
flange
50 H 6 M 500 (800) Inspect duct for proper sealing/air leaks
Drive belt 50 H 6 M 500 (800) Inspect; adjust; replace as needed
Cooling system (if applicable) 50 H 6 M 500 (800) Inspect coolant strength seasonally;
pressure test system yearly
? Oil lines, fasteners 50 H 6 M 1000 (1600) Inspect for leaks and loose fittings
? Engine oil and filter change 100 H 6 M 1000 (1600) Change the oil and filter
? Front gearcase oil 100 H 12 M 1000 (1600) Change fluid
? Transmission oil 100 H 12 M 1000 (1600) Change fluid
D Fuel system 100 H 12 M 1000 (1600) Cycle key to pressurize fuel pump;
check for leaks at fill cap, fuel lines/rail
and fuel pump; replace lines every two
years
? Radiator (if applicable) 100 H 12 M 1000 (1600) Inspect; clean external surfaces
? Cooling Hoses (if applicable) 100 H 12 M 1000 (1600) Inspect for leaks
? Engine mounts 100 H 12 M 1000 (1600) Inspect
Exhaust muffler/pipe 100 H 12 M 1000 (1600) Inspect
Drive shafts 100 H 12 M 1000 (1600) Remove and grease
? Wiring 100 H 12 M 1000 (1600) Inspect for wear, routing, security; apply
dielectric grease to connectors sub-
jected to water, mud, etc.
D
?
Clutches (drive and driven) 100 H 12 M 1000 (1600) Inspect; clean; replace worn parts
D Front wheel bearings 100 H 12 M 1000 (1600) Inspect; replace as needed
Fuel filter/water separator 150 H 12 M - Replace fuel filter / water separator
D Alternator belt 250 H - - Inspect; check tension
D Brake fluid 200 H 24 M 2000 (3200) Change every two years
Suspension bushings 250 H 24 M 2000 (3200) Inspect; replace if necessary
Spark arrester 300 H 36 M 3000 (4800) Clean out
D Alternator belt 500 H - - Replace
D Timing belt 4000 H - - Replace
? Coolant - 60 M - Replace coolant
D Valve clearance - - 5000 (8000) Inspect; adjust as needed
D Toe adjustment - Inspect periodically; adjust when parts
are replaced
D
?
Auxiliary brake (if equipped) - Inspect daily; adjust as needed
Headlight aim - Adjust as needed