Polaris Ranger 1000 Diesel User Manual (English)

Questions and Answers:

S
Shawn McintyreAug 2, 2025
What to do if my Polaris Ranger 1000 Diesel Offroad Vehicle engine turns over but fails to start?
- S
  Scott CortezAug 2, 2025
  If your Polaris Offroad Vehicle's engine turns over but doesn't start, the following could be the reasons: * The vehicle is out of fuel, in which case you should refuel. * The fuel filter or water separator is clogged, requiring replacement. * The air filter is clogged and needs replacement. * There is water in the fuel; drain the fuel system, refuel, and replace the fuel filter/water separator. * The fuel is old or not recommended; replace it with fresh, recommended fuel. * There is low battery voltage; recharge the battery to 12.8 VDC. * There is a mechanical failure, defective glow plug, stop solenoid or fuel pump.
M
michelleandrewsAug 7, 2025
What to do if my Polaris Offroad Vehicle engine stops or loses power?
- D
  David GonzalezAug 7, 2025
  If your Polaris Offroad Vehicle engine stops or loses power, consider the following possible causes: * Poor or incorrect fuel quality: Replace with recommended fuel. * Clogged fuel filter: Replace the filter. * Clogged air filter: Replace the filter. * Loose ignition connections: Check and tighten all connections. * Water in the fuel: Replace with new fuel. * Kinked or plugged fuel tank vent line: Inspect and replace the line. * Out of fuel: Refuel. * Low battery voltage: Recharge the battery to 12.8 VDC. * Overheated engine: Clean radiator screen and core, clean engine exterior, operate at lower load.
K
Kelly HansonAug 11, 2025
Why does my Polaris Ranger 1000 Diesel Offroad Vehicle engine run irregularly, stall, or misfire?
- J
  Julie ByrdAug 11, 2025
  Your Polaris Offroad Vehicle engine might run irregularly, stall, or misfire due to: * Poor fuel quality or incorrect fuel: Replace with recommended fuel. * Low fuel level: Refuel. * Clogged fuel filter: Replace the filter. * Clogged air filter: Replace the filter. * Loose ignition connections: Check and tighten all connections. * Water in fuel: Replace with new fuel. * Kinked or plugged fuel tank vent line: Inspect and replace.
J
john03Aug 16, 2025
How to fix Polaris Ranger 1000 Diesel engine that doesn't turn over?
- N
  Natalie GoodmanAug 17, 2025
  If your Polaris Offroad Vehicle engine doesn't turn over, check these potential issues: * Low battery voltage: Recharge the battery to 12.8 VDC. * Loose battery connections: Check and tighten all connections. * Loose starter connections: Check and tighten all connections. * Loose electronic control box connections: Inspect, clean, and reinstall connectors.
B
bondjenniferAug 22, 2025
Why does my Polaris Ranger 1000 Diesel Offroad Vehicle drive belt wear or burn?
- M
  Maria RichAug 22, 2025
  Drive belt wear or burn in your Polaris Offroad Vehicle can occur due to several reasons: * Driving onto a pickup or tall trailer in high range. * Starting out going up a steep incline. * Driving at low RPM or ground speed (3-7 MPH). * Insufficient warm-up at low ambient temperatures. * Slow/easy clutch engagement. * Towing/pushing at low RPM/low ground speed. * Utility use/plowing. * Stuck in mud or snow. * Climbing over large objects from a stopped position. * Belt slippage from water or snow ingestion into the PVT system. * Clutch malfunction. * Poor engine performance. * Slippage from failure to warm up belt. * Wrong or missing belt. * Improper break-in.
K
kennethhallAug 27, 2025
Why does my Polaris Offroad Vehicle engine backfire?
- C
  Cheryl GriffinAug 27, 2025
  Your Polaris Offroad Vehicle engine may backfire due to: * Old or non-recommended fuel: Replace with fresh, recommended fuel. * Loose ignition connections: Check all connections and tighten. * Water present in fuel: Replace with fresh, recommended fuel.

Polaris Ranger 1000 Diesel Specifications

General

Brand	Polaris
Model	Ranger 1000 Diesel
Category	Offroad Vehicle
Language	English

Summary

INTRODUCTION

Signal Words and Symbols

Defines signal words like DANGER, WARNING, CAUTION, NOTICE and safety signs.

General Safety Warnings

Lists critical warnings about vehicle operation, hazards, and potential for injury or death.

Vehicle Identification Numbers

Guides on recording VIN, frame VIN, engine serial number, and key number for reference.

SAFETY

Safe Riding Gear

Details essential safety gear including helmet, eye protection, gloves, long sleeves, pants, and boots.

Operator Safety

Provides comprehensive safety guidelines for operating the vehicle to prevent injury or death.

Safety Labels and Locations

Identifies important safety labels on the vehicle and their purpose.

Driving Hazards and Precautions

Addresses safety for slippery terrain, frozen water, damaged vehicles, speed, pavement, public roads, and unfamiliar terrain.

FEATURES AND CONTROLS

Component Locations

Illustrates and labels key components of the vehicle for identification.

Console

Describes the console features including instrument cluster, auxiliary outlets, and gear selector.

Switches

Details the operation of ignition, mode, light, and AWD/differential lock switches.

Seat Belts

Explains how to properly wear and inspect the three-point seat belts.

Instrument Cluster

Introduces the instrument cluster and the rider information center.

OPERATION

Break-In Period

Outlines the initial break-in procedure for the engine, drivetrain, and PVT system.

Pre-Ride Inspection

Provides a checklist of items to inspect before each ride for safe operation.

Fuel Recommendations

Specifies recommended diesel fuels and compliance with warranty requirements.

Starting the Engine

Step-by-step instructions for safely starting the vehicle's engine.

Driving Procedure

Outlines the basic steps for safely operating the vehicle from start to finish.

Hauling Cargo

Details crucial precautions for safely hauling cargo to prevent accidents.

All Wheel Drive (AWD)

Explains how to engage and disengage the All Wheel Drive system.

WINCH GUIDE

Winch Safety Precautions

Lists essential safety warnings and precautions for operating a winch.

Winch Operation

Covers general guidelines and thinking process for safe winch operation.

Shock Loading

Explains the dangers of shock loading the winch cable and how to avoid it.

EMISSION CONTROL SYSTEMS

Exhaust Emission Control System

Explains how the exhaust system controls emissions and fuel requirements.

Noise Emission Control System

Advises against modifying engine components that affect noise compliance.

MAINTENANCE

Periodic Maintenance Chart

Introduces the maintenance schedule, defining severe use and chart keys.

Engine Oil

Provides step-by-step instructions for checking the engine oil level.

POLARIS Variable Transmission (PVT) System

Outlines owner responsibilities and maintenance for the PVT system.

Brakes

Details brake system warnings and procedures for inspecting and changing brake fluid.

Tires

Covers tire maintenance, tread depth, and axle/wheel nut torque specifications.

Battery

Covers battery maintenance, removal, installation, and storage procedures.

Transporting the RANGER

Provides procedures and safety warnings for transporting the vehicle.

SPECIFICATIONS

RANGER Diesel

Presents detailed specifications for the RANGER Diesel model.

RANGER CREW Diesel

Presents detailed specifications for the RANGER CREW Diesel model.

TROUBLESHOOTING

Drive Belt Wear/Burn

Identifies common causes for drive belt wear or burning and their solutions.

Engine Turns Over, Fails to Start

Provides troubleshooting steps for when the engine cranks but doesn't start.

Engine Stops or Loses Power

Lists causes and solutions for the engine stopping or losing power during operation.

WARRANTY

Limited Warranty

Outlines the general terms and duration of the limited warranty.

Warranty Coverage And Exclusions

Details what is covered and excluded under the limited warranty.

How To Obtain Warranty Service

Guides on the process for obtaining warranty service from a dealer.

CALIFORNIA AND FEDERAL EMISSION CONTROL WARRANTY STATEMENT

Presents the emission control warranty statement from Kohler Co.

MAINTENANCE LOG

Related product manuals

Polaris RANGER 1000 2023

171 pages

Polaris RANGER 1000 2021

610 pages

Polaris RANGER XP 1000 2018-2019

561 pages

Polaris RANGER 150 EFI 2020

147 pages

Polaris Ranger RZR 170 2013

Polaris Ranger 800 EFI

116 pages

Polaris Ranger 1000 Diesel User Manual

Table of Contents