6. Reinstall the air filter (if clean) or install a new air filter (if soiled). Do not
attempt to clean the air filter.
NOTICE
Use of a non-POLARIS-approved air filter may cause engine damage. Always
use a POLARIS-approved replacement filter. See the POLARIS products
chapter for part numbers.
7. Make sure the filter is fully seated on the intake boot and that there is no gap
between the filter and boot after installation. Tighten the worm gear clamp to
3 Nm (26 in. lbs.).
8. Reinstall the air box cover. Make sure both hinges are fully inserted. Secure
the cover clips.
SPARK ARRESTOR
WARNING
Failure to heed the following warnings while servicing the spark arrestor could
result in serious injury or death.
• Do not perform service on the spark arrester while the system is hot. Allow
components to cool sufficiently before proceeding.
• Wear eye protection and gloves.
• Never operate without the spark arrestor.
• Never run the engine in an enclosed area. Exhaust contains poisonous
carbon monoxide gas.
127
MAINTENANCE
To Next Page
Loading...
