71
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item Hours/
Miles
Frequency Remarks
Spark plug 100 hrs. 12 months Inspect; replace as needed
J Ignition Timing 100 hrs. 12 months Inspect; adjust as needed
J Fuel system 100 hrs. 12 months Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor; re-
place lines every two years
J Fuel filter 100 hrs. 12 months Replace annually
J Clutches
(drive and driven)
100 hrs. 12 months Inspect; clean
Engine mounts 100 hrs. 12 months Inspect
J Oil filter 100 hrs. 12 months Replace
J Shift selector box 200 hrs. 24 months Change lubricant every two
years
J Brake fluid 200 hrs. 24 months Change every two years
Spark arrestor 300 hrs. 36 months Clean out
J Front and rear
wheel bearings
300 hrs. 36 months Inspect; replace as needed
Idle speed As required Adjust
Recoil housing As required Drain moisture out after rid-
inginwater
J Toe adjustment As required Periodic inspection; adjust
when parts are replaced
Headlight aim As required Adjust as needed
" More often under severe use, such as dirty or wet conditions
J Dealer service item
Improperly performing the procedures marked with a J could
result in component failure and lead to serious injury or death.
Have an authorized Polaris dealer perform these services.
WARNING
To Next Page
Loading...
Need help?
General
