Poulan Pro PB20A46 User Manual (English)

Questions and Answers:

M
Matthew GreenAug 19, 2025
How to fix Poulan Pro PB20A46 that will not start?
- E
  Eric OlsonAug 20, 2025
  If your Poulan Pro Lawn Mower won't start, several factors could be the cause. First, make sure the fuel tank is full. If that's not the issue, ensure the engine is choked properly, as described in the Operation section. If the engine is flooded, wait a few minutes before trying again. Other potential causes include a bad spark plug (replace it), a dirty air filter (clean or replace it), a dirty fuel filter (replace it), or water in the fuel (empty the tank and carburetor, refill with fresh gasoline, and replace the fuel filter). Also, check for loose or damaged wiring. If none of these solutions work, the engine valves may be out of adjustment, and you should contact an authorized service center.
A
angelabrooksAug 21, 2025
Why is my Poulan Pro PB20A46 Lawn Mower hard to start?
- J
  Jerry ContrerasAug 22, 2025
  If your Poulan Pro Lawn Mower is hard to start, consider these possibilities: The air filter might be dirty, so clean or replace it. The spark plug could be bad, requiring replacement. A weak or dead battery could be the issue; recharge or replace it as necessary. Also, check the fuel filter; if it's dirty, replace it. Stale or dirty fuel can also cause problems, so empty the fuel tank and refill it with fresh, clean gas. Finally, inspect the wiring for any loose connections or damage. If these steps don't resolve the issue, the engine valves may need adjustment by an authorized service center.
C
Christine WellsAug 25, 2025
Why does my Poulan Pro PB20A46 engine click but not start?
- B
  Bruce CowanAug 25, 2025
  If your Poulan Pro Lawn Mower engine clicks but doesn't start, the battery may be weak or dead, requiring a recharge or replacement. Corroded battery terminals can also cause this issue, so clean them thoroughly. Inspect the wiring for any loose connections or damage. If these steps don't resolve the problem, the solenoid or starter might be faulty and need to be checked or replaced.
J
Jennifer LeeAug 26, 2025
What to do if Poulan Pro PB20A46 Lawn Mower blades will not rotate?
- T
  Tim ThomasAug 26, 2025
  If the mower blades of your Poulan Pro Lawn Mower will not rotate, there might be an obstruction in the clutch mechanism; remove it. The mower drive belt could be worn or damaged, so replace it. A frozen idler pulley or blade mandrel could also be the cause, requiring replacement.
S
savannahdawsonAug 30, 2025
What to do if Poulan Pro PB20A46 Lawn Mower engine will not turn over?
- J
  John ClarkAug 30, 2025
  If the engine of your Poulan Pro Lawn Mower won't turn over, make sure you're depressing the brake pedal. Also, ensure the attachment clutch is disengaged. A weak or dead battery could be the culprit, so recharge or replace it. Check for a blown fuse and replace it if necessary. Clean any corrosion from the battery terminals. Inspect all wiring for looseness or damage. If the problem persists, the ignition switch, solenoid, or starter might be faulty and need checking or replacement. If those don't solve the problem, contact an authorized service center to inspect the operator presence switches.
K
kurt54Sep 1, 2025
How to fix Poulan Pro PB20A46 Lawn Mower poor uneven cut?
- C
  Christopher ScottSep 1, 2025
  If your Poulan Pro Lawn Mower is leaving an uneven cut, the blade might be worn, bent, or loose; replace the blade and tighten the blade bolt. Check if the mower deck is level and adjust it if necessary. Buildup of grass, leaves, or trash under the mower can also cause an uneven cut, so clean the underside of the mower housing. Additionally, inspect the blade mandrel for bending and replace it if needed. Finally, check for clogged mower deck vent holes and clean around the mandrels to open them.
M
Martin GonzalezSep 3, 2025
Why Poulan Pro PB20A46 Lawn Mower has poor grass discharge?
- S
  Sara WelchSep 3, 2025
  If your Poulan Pro Lawn Mower has poor grass discharge, ensure the engine speed isn't too slow by placing the throttle control in the 'FAST' position. If you're moving too fast, shift to a slower speed. Wet grass can also cause poor discharge, so allow the grass to dry before mowing. Check if the mower deck is level and adjust it if necessary. Make sure the tire air pressure is correct and even. Inspect the blade for wear, bending, or looseness, and replace or tighten it as needed. Clean any buildup of grass, leaves, or trash under the mower. If the mower drive belt is worn, replace it. Ensure the blades are installed with the sharp edge down. If improper blades are used, replace them with the blades listed in the parts manual. Finally, clear any clogged mower deck vent holes.
S
Stephanie ReynoldsSep 4, 2025
What causes excessive vibration in Poulan Pro Lawn Mower?
- C
  Catherine CampbellSep 5, 2025
  If your Poulan Pro Lawn Mower is experiencing excessive vibration, the blade may be worn, bent, or loose. Replace the blade and tighten the blade bolt. The blade mandrel might also be bent, requiring replacement. Check for any loose or damaged parts and tighten or replace them as necessary.
L
Leslie RogersSep 7, 2025
Why Poulan Pro PB20A46 Lawn Mower headlights are not working?
- E
  Edward MoralesSep 7, 2025
  If the headlight(s) on your Poulan Pro Lawn Mower aren't working, first ensure the switch is turned 'ON'. If that's not the issue, the bulb(s) or lamp(s) may be burned out and need replacement. A faulty light switch could also be the cause, so check or replace it. Inspect the wiring and connections for looseness or damage. Finally, check the fuse and replace it if it's blown.
T
Thomas OlsenSep 8, 2025
What causes Poulan Pro PB20A46 Lawn Mower battery to not charge?
- D
  daniel69Sep 9, 2025
  If the battery of your Poulan Pro Lawn Mower will not charge, it could be due to bad battery cells, requiring a battery replacement. Poor cable connections can also prevent charging, so check and clean all connections. If equipped, a faulty regulator or alternator might be the cause, and you should replace them.

Poulan Pro PB20A46 Specifications

General

Brand	Poulan Pro
Model	PB20A46
Category	Lawn Mower
Language	English

Summary

Operator's Manual

Model PB20A46 Tractor

Identification of the tractor model and type.

Safety Rules

Cutting Machine Dangers

Cutting machine hazards, amputating hands/feet, throwing objects.

Prevent Accidental Starting

Disconnect spark plug wire to prevent accidental starting during maintenance.

Coasting Downhill Safety

Avoid coasting downhill in neutral to maintain control.

Towing Attachments Safety

Tow only recommended attachments and use caution on slopes.

Children Injury Risk

Safety warning about children's safety with the equipment.

Children Death Risk

Severe warning about children's injury or death risk.

General Operation Safety Rules

General guidelines for safe operation of the tractor.

Safe Slope Operation

Safe practices for operating the tractor on slopes.

Towing Safety

Guidelines for safely towing equipment with the tractor.

Gasoline Handling Safety

Safe handling of gasoline.

Product Specifications

Tractor Specifications

Technical details and specifications of the tractor.

Customer Responsibilities

Owner's Duties

Owner's duties for safe operation and maintenance.

Assembly

Unassembled Parts

Lists parts that are not assembled at the factory.

Assembly Tools

Lists necessary tools for assembling the tractor.

Unpack Tractor Carton

Instructions for unpacking the tractor from its shipping carton.

Check Battery

Procedure for checking the tractor's battery status.

Adjust Seat

Steps to adjust the operator's seat for comfort and safety.

Remove Tractor from Skid

Instructions for safely removing the tractor from its shipping skid.

Check Tire Pressure

Importance of proper tire inflation for cutting performance.

Check Deck Levelness

Ensuring the mower deck is properly leveled for optimal cutting.

Check Brake System

Verifying the proper function of the tractor's brake system.

Assembly Checklist

A checklist to ensure all assembly steps are completed correctly.

Operation

Operation Symbols

Explains the meaning of various symbols used on the tractor and in the manual.

Safety Alert Symbols

Explains the meaning of danger, warning, and caution symbols.

Know Your Tractor Controls

Familiarization with tractor controls and their locations.

Set Parking Brake

Procedure for setting and engaging the parking brake.

Stop Tractor and Blades

Instructions for stopping the mower blades and the tractor ground drive.

Use Throttle Control

How to operate the throttle control for starting and speed.

Move Forward and Backward

How to control tractor movement using drive pedals.

Adjust Mower Cutting Height

Steps to set the desired cutting height for the mower deck.

Operate Mower

How to engage and operate the mower blades.

Reverse Operation System (ROS)

Explanation and usage of the Reverse Operation System.

Safe Hill Operation

Safety precautions and procedures for operating on slopes.

Transport Tractor

Instructions for safely transporting the tractor.

Pre-Start Engine Checks

Pre-start checks including oil level and fuel.

Start Engine

Procedures for starting the tractor engine in warm and cold weather.

Mowing Tips

Practical advice for efficient and effective mowing.

Maintenance

Maintenance Schedule

Recommended maintenance tasks and their frequencies.

General Maintenance Advice

General advice on maintaining the tractor for warranty and longevity.

Before Each Use Checks

Daily checks and maintenance tasks before operating.

Check Brake Operation

How to check and adjust the tractor's brakes.

Tire Care

Maintenance advice for tires, including pressure and care.

Check Safety Systems

Checking the safety systems for proper function.

Mower Blade Care

Importance of sharp blades and replacement guidelines.

Mower Blade Removal

Steps for safely removing mower blades.

Battery Care

Information on the tractor's battery and its charging system.

Clean Battery Terminals

Procedure for cleaning battery terminals to ensure good connection.

Check V-Belts

Checking V-belts for wear and replacing them if necessary.

Transaxle Maintenance

Information regarding transaxle maintenance requirements.

Engine Lubrication

Guidance on engine oil type and viscosity for lubrication.

Change Engine Oil

Step-by-step instructions for changing the engine oil.

Replace Engine Oil Filter

Recommendation for replacing the engine oil filter.

Air Filter Service

Importance of servicing the air filter for engine performance.

Clean Air Screen

How to clean the air intake screen to prevent overheating.

Engine Cooling System

Maintaining the engine's cooling system for proper operation.

Replace Spark Plugs

When to replace spark plugs and their specifications.

Muffler Inspection

Inspecting and replacing the muffler and spark arrester.

Replace Fuel Filter

Procedure for replacing the in-line fuel filter.

General Cleaning

General cleaning instructions for the tractor.

Use Deck Washout Port

Instructions for using the deck washout port for cleaning.

Service and Adjustments

Remove Mower Deck

Detailed steps for removing the mower deck from the tractor.

Attach Mower Suspension Arms

Connecting the mower's side suspension arms to the chassis.

Attach Rear Lift Links

Connecting the mower's rear lift links to the tractor.

Attach Front Link

Connecting the front link assembly to the tractor's suspension bracket.

Level Mower Deck

Procedures for leveling the mower deck for optimal cutting.

Visual Side-to-Side Deck Adjustment

Adjusting mower deck levelness visually.

Precision Side-to-Side Deck Adjustment

Precise adjustment of mower deck side-to-side levelness.

Front-to-Back Deck Adjustment

Adjusting the mower deck for correct front-to-back tilt.

Replace Mower Blade Drive Belt

Steps for replacing the mower blade drive belt.

Replace Motion Drive Belt

Instructions for replacing the tractor's motion drive belt.

Check Brake System

How to check the brake system's performance.

Remove Wheel

Procedure for removing a wheel from the tractor axle.

Front Wheel Toe-In/Camber

Information on front wheel alignment settings.

Jump-Start Weak Battery

Safe procedures for jump-starting the tractor.

Replace Tractor Battery

Steps for safely installing a new tractor battery.

Replace Headlight Bulb

Instructions for replacing a headlight bulb.

Check Interlocks and Relays

Checking wiring for potential issues affecting tractor operation.

Replace Fuse

Procedure for replacing the tractor's fuse.

Remove Hood and Grill Assembly

Steps for removing the tractor's hood and grill.

Adjust Throttle Control Cable

Adjusting the throttle control cable if needed.

Storage

Prepare Tractor for Storage

Preparing the tractor for long-term storage.

Store Tractor Battery

Proper procedures for storing the tractor battery.

Prepare Engine Fuel System for Storage

Preparing the fuel system for storage to prevent gum deposits.

Change Engine Oil for Storage

Changing engine oil before storage.

Troubleshooting

Troubleshooting: Engine Won't Start

Identifies causes and corrections for engine starting issues.

Troubleshooting: Hard Starting

Common reasons and solutions for a hard-starting engine.

Troubleshooting: Engine Won't Crank

Diagnosing and fixing issues when the engine won't crank.

Troubleshooting: Engine Clicks, No Start

Troubleshooting when the engine makes clicking sounds but won't start.

Troubleshooting: Engine Loss of Power

Addressing issues related to the engine losing power during operation.

Troubleshooting: Excessive Vibration

Identifying causes and solutions for excessive vibration.

Troubleshooting: Engine Runs After Leaving Seat

Troubleshooting safety interlock failures.

Troubleshooting: Uneven Cutting

Diagnosing and fixing causes of uneven lawn cutting.

Troubleshooting: Blades Not Rotating

Identifying reasons why mower blades fail to spin.

Troubleshooting: Poor Grass Discharge

Solutions for issues causing poor grass discharge.

Troubleshooting: Headlights Not Working

Troubleshooting non-functional headlights.

Troubleshooting: Battery Not Charging

Diagnosing why the tractor battery is not charging.

Troubleshooting: Loss of Drive

Resolving problems related to the tractor losing its drive.

Troubleshooting: Engine Backfires on Shutdown

Troubleshooting engine backfiring when shutting down.

Troubleshooting: Engine Stalls in Reverse

Diagnosing why the engine stalls when shifting into reverse.

Suggested Guide for Sighting Slopes

Measure Slope Angles

A guide for measuring and understanding slope angles for safe operation.

Service Notes

General Service Reminders

General notes or reminders related to service.

Related product manuals

Poulan Pro Pro PB20H42YT

Poulan Pro Pro PB26H54YT

20 pages

LAWN TRACTOR PB22H46YT

28 pages

Poulan Pro PB20A46 User Manual

Table of Contents

Questions and Answers:

Poulan Pro PB20A46 Specifications

Summary

Operator's Manual

Model PB20A46 Tractor

Safety Rules

Cutting Machine Dangers

Prevent Accidental Starting

Coasting Downhill Safety

Towing Attachments Safety

Children Injury Risk

Children Death Risk

General Operation Safety Rules

Safe Slope Operation

Towing Safety

Gasoline Handling Safety

Product Specifications

Tractor Specifications

Customer Responsibilities

Owner's Duties

Assembly

Unassembled Parts

Assembly Tools

Unpack Tractor Carton

Check Battery

Adjust Seat

Remove Tractor from Skid

Check Tire Pressure

Check Deck Levelness

Check Brake System

Assembly Checklist

Operation

Operation Symbols

Safety Alert Symbols

Know Your Tractor Controls

Set Parking Brake

Stop Tractor and Blades

Use Throttle Control

Move Forward and Backward

Adjust Mower Cutting Height

Operate Mower

Reverse Operation System (ROS)

Safe Hill Operation

Transport Tractor

Pre-Start Engine Checks

Start Engine

Mowing Tips

Maintenance

Maintenance Schedule

General Maintenance Advice

Before Each Use Checks

Check Brake Operation

Tire Care

Check Safety Systems

Mower Blade Care

Mower Blade Removal

Battery Care

Clean Battery Terminals

Check V-Belts

Transaxle Maintenance

Engine Lubrication

Change Engine Oil

Replace Engine Oil Filter

Air Filter Service

Clean Air Screen

Engine Cooling System

Replace Spark Plugs

Muffler Inspection

Replace Fuel Filter

General Cleaning

Use Deck Washout Port

Service and Adjustments

Remove Mower Deck

Attach Mower Suspension Arms

Attach Rear Lift Links

Attach Front Link

Level Mower Deck

Visual Side-to-Side Deck Adjustment