Predator 79cc - User Manual

Questions and Answers

G
Gary MedinaJul 31, 2025
What to do if my Predator 79cc Engine stops suddenly?
- J
  James HallAug 1, 2025
  If your Predator Engine stops suddenly, there are several potential causes. A common reason is low oil; ensure the engine oil is filled to the proper level before each use. Another cause could be an empty fuel tank or impure/low-quality gasoline; refill with fresh 87+ octane stabilizer-treated unleaded gasoline, avoiding gasoline with more than 10% ethanol. A defective fuel tank cap creating a vacuum can also halt the engine; test or replace the cap. In some cases, a faulty magneto might be the issue, requiring service by a qualified technician. Lastly, a disconnected or improperly connected spark plug cap can cause sudden stops; make sure it is securely connected.
Q
qcolemanAug 6, 2025
Why Predator 79cc Engine misfires?
- J
  Jacqueline OconnorAug 6, 2025
  If the Predator Engine misfires, begin by checking the wire connections of the spark plug cap to ensure it's not loose. An incorrect spark plug gap or a damaged spark plug can also cause misfires, so re-gap or replace the spark plug as needed. A defective spark plug cap itself may be the problem, requiring replacement. Using old or low-quality gasoline can also lead to misfires; switch to fresh 87+ octane stabilizer-treated unleaded gasoline, ensuring it contains no more than 10% ethanol. Finally, incorrect compression can cause misfires; diagnose and repair the compression issue, referring to the Engine will not start: COMPRESSION RELATED section.
R
robinsonjulieAug 10, 2025
What causes Predator Engine to knock?
- C
  Carla KellyAug 10, 2025
  If your Predator Engine is knocking, it could be due to several reasons. Old or low-quality gasoline is a common cause; make sure you're using fresh 87+ octane stabilizer-treated unleaded gasoline, avoiding gasoline with more than 10% ethanol. Another possibility is that the engine is overloaded; do not exceed the equipment’s load rating. Lastly, incorrect spark timing, deposit buildup, a worn engine, or other mechanical problems could be responsible, requiring diagnosis and service by a qualified technician.
S
Shawn HardingAug 15, 2025
How to fix Predator Engine backfire?
- A
  Ariel AlvaradoAug 15, 2025
  If your Predator Engine is backfiring, it could be due to impure or low-quality gasoline; use fresh 87+ octane stabilizer-treated unleaded gasoline, ensuring it has no more than 10% ethanol. If the engine is too cold, use cold weather fuel and oil additives to prevent backfiring. Other potential causes include a stuck intake valve or an overheated engine, which would require a qualified technician to diagnose and service the engine, or incorrect timing, which requires checking the engine timing.
J
John JonesAug 20, 2025
What to do if Predator Engine stops when under heavy load?
- R
  Rachel HancockAug 20, 2025
  If your Predator Engine stops when under a heavy load, it could be due to a dirty air filter; try cleaning or replacing the filter element. Another possible cause is the engine running cold; allow the engine to warm up properly before operating the equipment.
M
Melanie GrimesOct 25, 2025
Why my Predator Engine will not start?
- S
  spencerrobertsonOct 26, 2025
  If your Predator Engine won't start, several fuel-related issues could be the cause. First, ensure the fuel tank isn't empty and the fuel valve is open; if not, fill it with fresh 87+ octane stabilizer-treated unleaded gasoline, avoiding gasoline with more than 10% ethanol. If the engine is cold, make sure the choke is in the CHOKE position. Also, low-quality, old gasoline or gasoline with too much ethanol can be a culprit; in this case, you should use fresh, recommended gasoline and clean out the fuel system. Other potential issues include a carburetor that isn't primed (pull the starter handle), dirty fuel passageways (clean with fuel additive), a stuck carburetor needle (tap the carburetor's float chamber gently), too much fuel in the chamber (turn the choke to RUN, remove the spark plu...

Summary

Safety Information

Warning Symbols and Definitions

Explains safety alert symbols and their meanings for potential hazards.

Symbol Definitions

Defines symbols used in the manual related to safety, property, and statements.

General Safety Warnings

Provides crucial warnings about potential fire, serious injury, and death from improper use.

Setup and Installation

Setup Precautions

Outlines essential safety steps and precautions before setting up the engine.

Engine Mounting Instructions

Details the process and considerations for securely mounting the engine.

Operating the Engine

Pre-Start Checks

Instructions for inspecting the engine and equipment before starting.

Checking and Filling Engine Oil

Procedure for checking and filling the engine oil level to prevent damage.

Checking and Filling Fuel

Steps for safely checking and filling the fuel tank with appropriate gasoline.

Starting the Engine

Guides on preparing and starting the engine, including break-in procedures.

Manual Start Procedure

Step-by-step instructions for starting the engine manually using the starter handle.

Stopping the Engine

Describes how to safely stop the engine in normal and emergency situations.

Maintenance and Servicing

Cleaning, Maintenance, and Lubrication Schedule

A schedule outlining routine maintenance tasks and their frequency.

Engine Oil Change Procedure

Detailed instructions for safely draining and refilling the engine oil.

Air Filter Element Maintenance

Procedures for cleaning or replacing the air filter element for optimal performance.

Spark Plug Maintenance

Guidance on inspecting, cleaning, and replacing the spark plug for proper ignition.

Engine Storage Preparation

Steps to prepare the engine for long-term storage to prevent damage.

Troubleshooting Guide

Engine Start Failures

Lists common causes and solutions for when the engine fails to start.

Engine Performance Issues

Addresses issues like engine misfires, sudden stops, and knocking.

Warranty Information

Limited 90 Day Product Warranty

Outlines the basic warranty coverage and limitations for the product.

Emission Control System Warranty

Details the warranty specific to the engine's emission control system components.

Parts and Diagrams

Parts List

A comprehensive list of all parts with their descriptions and quantities.

Assembly Diagram

A visual representation of how the engine components are assembled.

Mounting and Power Take-Off Diagrams

Diagrams showing engine mounting hole specifications and PTO dimensions.

Predator 79cc Specifications

General

Engine Type	4-stroke OHV
Displacement	79cc
Bore x Stroke	52 mm x 37 mm
Compression Ratio	8.5:1
Fuel Type	Unleaded gasoline
Starting System	Recoil
Ignition System	Transistorized magneto
Governor Type	Mechanical
Oil Capacity	0.37 quarts
Shaft Diameter	5/8 in
Shaft Size	5/8 inch
Fuel Capacity	0.95 liters (0.25 gallons)
Horsepower	3 HP

Related product manuals

Predator 68124

20 pages