Prestige Solo 110 User Manual

prestige
Solo
80 250
110 299
155 399
175
Water Boiler
Warranty Registration Card must be filled out by the customer and mailed within thirty (30) days of installa-
tion in order to gain warranty coverage.
When receiving the PRESTIGE Solo unit, any claims for damage or shortage in shipment must be filed
immediately against the transportation company by the consignee.
Leave all documentation received with appliance with owner for future reference.
2015-9 Prestige ACVMax Install Manual
If the information in this manual is not followed exactly, a fire or explosion may
result causing property damage, personal injury or death.
FOR YOUR SAFETY
• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of
this or any other appliance.
• WHAT TO DO IF YOU SMELL GAS
- Do not try to light any appliance
- Do not touch any electrical switch; do not use any phone in your building.
- Immediately call your gas supplier from a neighbor’s phone. Follow the gas
supplier’s instructions.
- If you cannot reach your gas supplier, call the fire department.
Installation and service must be performed by a qualified installer, service agency or the
gas supplier.
L
I
S
T
E
D
WARNING
NOTICE
Revised Date: 12/15/15
* I N S T A L L A T I O N A N D M A I N T E N A N C E *
* I N S T A L L A T I O N A N D M A I N T E N A N C E *
M A N U A L
M A N U A L

Prestige Solo 110 Specifications

General

Efficiency	95% AFUE
Boiler Type	Condensing
Heat Exchanger Material	Stainless Steel
Fuel Type	Natural Gas / Propane
Input BTU	110, 000 BTU/h
Ignition Type	Electronic

Summary

Installation and Maintenance Manual

SECTION II - Combustion Air and Venting

Combustion Air Contamination

Identifies potential contaminants affecting combustion air.

Ventilation and Combustion Air Requirements - Category IV

Specifies air requirements for Category IV systems.

SECTION IV - Boiler Piping

General Piping Requirements

Overall rules for boiler system plumbing.

Low Water Cutoff Device

Description and requirements for the LWCO.

SECTION V - Installing Vent / Combustion Air & Condensate Drain

Installing Condensate Drain Assembly

Steps for correctly installing the condensate drain.

SECTION VI - Gas Piping

Natural Gas

Propane Gas

SECTION IX - ACVMax Operation

Home Screen

EZ Setup

Boiler Information

SECTION X - Start-Up Preparation

Boiler System Fluid Requirements

Check For Gas Leaks

Procedures for detecting gas leaks.

SECTION XI - Start-Up Procedures

PRESTIGE Solo Start-Up

Step-by-step guide for starting the unit.

PRODUCT & SAFETY INFORMATION

SECTION XVII- MAINTENANCE PROCEDURES

Perform Start-up and Checkout Procedures

Executing the start-up and checkout checklist.