Pro.Mecc Freccia - Page 18

Maintenance Manual V001
FRECCIA
Maintenance Manual V001
FRECCIA
Seite 34 Seite 35
 Daily
first 5
hours
25
hours
100
hours
200
hours
500
hours
1000
hours
10 000
hours
CHECK LIST FROM ENGINE’S MANUFACTURER MANUAL
C       

       
CHECK LIST FROM PROPELLER MANUFACTURER MANUAL
C       

       
WING AND TAIL SURFACES
    SC SC O
surface and structure condition
C C C C SC   
deflection without free play
C    SC   
bearings - moving parts‘ bushing
C  LO LO SC   
Lights (if installed)
C       
self-adhesive sealing tape
C       
horizontal tail mount
C C C C SC   
drain holes
C   CL    

       
FUSELAGE
     SC SC O
surface and structure condition
C C C C SC  SC 
elevator control tube bearing
C   LO SC   
undercarriage struts attaching points
C C C SC SC   
doors, hinges
C   LO SC   
rudder control wires and hinges
C   LO SC   

       
CABIN
     SC SC O
control levers, instrument panel, seats
C   C    
control levers‘ free play
C C C C SC   
instruments and pitot-static
C
check yearly
glass surface: clean, attached
C       
safety harnesses and attach. points
C   C    
parachute rescue system activation handle
C
see manufacturer‘s manual
wing connectors: fuel, electrical
C C C C SC   
bolts and spar pins
C C C C SC   
wing main bushing, control connectors
C C C C SC   

       
UNDERCARRIAGE
     SC SC O
tires
C
replace on condition or every 5 years
main strut, tail/nose wheels strut condition
C C C C SC   
wheel axis and wheels
   C SC   
hyd. brake lines
C   C SC  R 
brake fluid
C   C SC
R(500 hrs or 5 years)
brake discs
   C SC
(R on condition)
wheel bearing
   C SC R  
wheel fairings
C   C C   

       
CONTROLS (LO every 100 hrs or yearly)
     SC SC R
general free play
C   C SC   
control stick
C   LO SC   
rudder pedals (damage, centered,paral.)
C   C SC   
rudder wire rope
C   C SC   
bolts, visible bearings (tail, fuselage)
C   C SC   
difficult-to-reach bearings (wings, under cabin floor)
   LO SC LO+SC  
aileron, elevator and rudder hinges
C   LO SC   
flap handle
C   C SC   
elevator trim
C   C SC   

       
ENGINE
       
In addition to Rotax manual:
       
four-strokes engines (overhaul every 2000 hours)

engine cover screws
C C  C    
engine mount
C C  SC    
engine mount dumpers and other rubber parts
 C  SC
R every 500 hrs or 5 years
air filters
C C  CL  SC  
electric terminals, joints and connectors, hoses, radiator mount
C C  SC    
exhaust muffler
C C  SC  SC  
exhaust pipe springs and fire protection
C C  SC  R  
throttle, choke, propeller wire drive
   SC  R  

       
ENGINE CONTROL
       O
choke and throttle lever wire ropes
C  
C+LO
SC R  
levers
C   C SC   

       
PROPELLER AND SPINNER See manufacturer‘s manual
surface condition
C       
fastening bolts
  C C R   
propeller pitch
C    SC   
propeller balance
C     SC  

       
FUEL SYSTEM O every 500 hrs or 5 years
general leakage
C   SC SC SC  
water inside gascolator
C  SC SC SC SC  
dirt and gascolator filter
C CL CL CL CL R  
wing fuel tank caps
C       
fuel tank caps o-ring
   
R every 500 hrs or 5 years
fuel valves and leakage
C       

       