Pulsar AS 150 - Drive Chain Cleaning; Drive Chain Lubrication

Periodic Maintenance Information
Drive chain must be cleaned & lubricated as
per periodic maintenance schedule.
Drive Chain (O-ring type)
• ‘O’ rings must always be kept wet for
best performance hence lubricate every
500 Km.
• O-ring chain lubrication can easily be
done by owners using Bajaj ‘Chain Lube
Spray Can’ available with Bajaj dealers,
or equivalent. Ensure that the lubricant
does not damage the rubber 'O' rings.
Method of O-ring Chain Lubrication :
• Park vehicle perpendicular to the ground on level
surface as mentioned in page no. 21 (6.1). Clean
the chain by using lint free cloth (If excessive
mud / slush found approach Bajaj Service Center
for proper cleaning)
• Shake the can vigorously by holding vertically
upright till the noise of steel ball inside heard
uniformly.
• Hold spray can at the back of rear sprocket with
extension tube nose at 5~10 cm.
• Rotate the wheel in reverse direction & spray the
lube on middle portion of the chain up to full
length of the chain.
Drive
Chain
Cleaning
Drive
Chain
Lubrication
28