Rayco RG74T-R - Page 53

RG74T-R Operator · Service · Maintenance
800.392.2686
53
12"
PLUG '12'
ECM
TYPE 'J'
Terminal Legend
A - DEUTSCH HDP26-24-31SE (24-31 PLUG W/SOCKETS)
B - BUSSMANN HHG OR EQ.
C - DEUTSCH HD10-9-1939P W/NICKEL PLATED TERMINALS IN'A' & 'B' AND GOLD PLATED TERMINALSIN 'C' & 'D'
D - TYCO/AMP 927770-3, 828904-1; CARLING WCH CONNECTOR 190-31214-001
E - DEUTSCH DT06-3S, W/W3S-1939-P012 WEDGELOCK, & GOLD PLATED TERMINALS
F - DEUTSCH DT06-3S, W/W3S WEDGELOCK
G - DEUTSCH DT06-2S, W/W2S WEDGELOCK
H - HELLA RELAY CONNECTOR KIT H84-709-011 OR EQ.
J - DELPHI 13964572 96 WAY, W/COVER LEVER 15494614 OR COVER LEVER W/ORANGE TAB 13964580,
RUBBER BOOT 13957208 & STRAIN RELIEF 13856709
K - WEATHER PACK PLUG #12015792 (W/FEMALE TERM. & SEAL)
L - RING TERMINAL FOR 5/16" STUD - INSULATED - W/ADH. HEAT SHRINK
M - RING TERMINAL FOR #8-32 STUD - INSULATED - W/ADH. HEAT SHRINK
N - RING TERMINAL FOR #10 STUD - INSULATED - W/ADH. HEAT SHRINK
P - RING TERMINAL FOR #3/8 STUD - INSULATED - W/ADH. HEAT SHRINK
Q - RING TERMINAL FOR #1/4 STUD - INSULATED - W/ADH. HEAT SHRINK
R - DELPHI 150 SERIES 3 PIN (12110293), DELPHI TERMINAL (12048074), DELPHI LOCK (12052845)
S - DEUTSCH DT06-3S, W/W3S-P012 WEDGELOCK, & GOLD PLATED TERMINALS
T - DEUTSCH DT06-6S, W/W6S WEDGELOCK
U - DEUTSCH DTM04-4P, W/WM-4P WEDGELOCK
V - DEUTSCH DT04-3P, WITH (3) 114017 PLUG
W- RING TERMINAL FOR 1/2" STUD - INSULATED - W/ADH. HEAT SHRINK
X - DEUTSCH DT04-3P-P007
Y- DEUTSCH DT06-3S-P006
Z - VTE SERIES 212 (212N1V02) OR EQ. (RED)
AA- RESISTOR- 1K OHM, 2W (NEWARK 78R4771 OR EQ.)
BB- DEUTSCH HDC16-9-JDL DUST CAP W/ TETHER CORD
PLUG '47'
IGNITION
TYPE 'T'
PLUG '48'
E-STOP
TYPE 'U'
PLUG '03'
DIAGNOSTIC
TYPE 'C' AND "BB"
PLUG '07'
RECEIVER CAN
TYPE 'E', 'X', 'Y'
PLUG '46'
ECM CAN
TYPE 'E' AND 'X'
PLUG '45'
COOLANT LEVEL
TYPE 'R'
ALTERNATOR +
TYPE 'P'
ALT FUSE (ST)
125A TYPE 'L'
STARTER B+
TYPE 'W'
PLUG '10'
RUN PWR
RELAY
TYPE 'H'
PLUG '09'
RECEIVER
INTERCONNECT
TYPE 'G'
STARTER B-
TYPE 'W'
ALT FUSE (ALT)
125A TYPE 'L'
ALTERNATOR -
TYPE 'P'
PLUG '49'
DISPLAY INTERCONNECT
TYPE 'F' & 'V'
PLUG '37'
CW PUMP
TYPE 'G'
PLUG '08'
HYD OIL LVL
TYPE 'F'
PLUG '13'
COMMAND
CUT
SWING CONTROL
VALVE
TYPE 'G'
17 18
HYD
TEMP
TYPE 'N'
HYD
TEMP
TYPE 'N'
ECU FUSE 30A
TYPE 'M'
#8 RING
23
22
PLUG '20'
WATER IN
FUEL
TYPE 'G'
KEY FUSE 20A
TYPE 'M'
#8 RING
24
START SOL PWR
TYPE 'L' & 'Z'
5/16 RING
STARTER PWR
TYPE 'L' & 'Z'
5/16 RING
2827
PREHEAT SOL SIG
TYPE 'N'
#10 RING
PREHEAT SOL GRD
TYPE 'N'
#10 RING
3231
START SOL SIG
TYPE 'N'
#10 RING
START SOL GRD
TYPE 'N'
#10 RING
3029
36
PLUG '21'
CW MOTOR
TYPE 'G'
38 40
41 42
43 44
PLUG '11'
ECM CAN
TYPE 'E' AND 'X'
3"
6"
6"
6"
4"
6"
8"
6"
12"36"
18"
16"16"
8"10"
15"12"
32"
4"
4"
12"
12"
18" 4"12"2"
20"
4"
2"
2"
2"
1"
6" 6"6"
6" 6" 6"
12"
20"
114"
18"
18"
12"4"
8"
2" 2"
28"
6"
4"
20"
3"
4"
39
STARTER SOL
TYPE 'Q'
16
ENGINE
GRD
TYPE 'P'
ENGINE
GRD
TYPE 'P'
15
25
COM GRD
BATTERY
TYPE 'P' 3/8 RING
PLUG '02'
DISPLAY FUSE 20A
TYPE 'B'
28"
12"
12"
COM GRD
BATTERY
TYPE 'P' 3/8 RING
26
PLUG '04'
THROTTLE SWITCH
TYPE 'D'
12"
8"
6"
2"
2"
NO
LOOM
PLUG '19'
CHARGE
FILTER
TYPE 'G'
NOTE: CONNECTOR '01' PIN # 01-3, 01-4 FOR
CAN-BUS TO BE GOLD PLATING OVER NICKEL.
ALL OTHERS TO BE NICKEL PLATED.
28"
2"
START SOL FUSE
30A TYPE 'M'
#8 RING
RUN PWR FUSE
30A TYPE 'M'
#8 RING
PLUG '01'
DISPLAY
TYPE 'A'
50
#50
RESISTOR
TYPE "AA"
WIRE LENGTH TOLERANCE
LESS THAN 6" +1/4" -0"
6" TO 40" +1/2" -0"
40" TO 100" +3/4" -0"
100" TO 200" +1" -0"
GREATER THAN 200" +1-1/2" -0"
Main Wiring Harness 35170-G