Home
Raypak
Temperature Controller
Temp-Tracker
Raypak Temp-Tracker User Manual
5
of 1
of 1 rating
36 pages
Give review
Manual
Specs
To Previous Page
To Previous Page
Loading...
36
www
.ray
p
a
k
.com
Raypak,
Inc.,
2151
Eastman
Avenue,
Oxnard,
CA
93030
(805)
278-5300
Fax
(805)
278-9725
Litho
in
U.S.A.
35
Table of Contents
Table of Contents
3
Menu
3
Introduction
3
User Interface
3
DIP Switch Settings
4
Display
4
Powering up the Controller
4
Item
4
Sequence of Operation
4
Primary/Secondary Piping
5
Modes of Operation (Mode)
5
External Target Temperature Input and Override with Primary Piping
7
External Direct Drive Operation
7
Staging Mode (STGMODE)
8
Manual Differential
8
Heater Differential (DIFF)
8
Code Descriptions
8
Interstage Delay on (on DLY)
9
Interstage Delay off (off DLY)
9
Minimum on Time (MIN ON)
9
Interstage Differential (STG DIFF)
9
Heater Minimum (BOIL MIN)
10
Heater Maximum (BOIL MAX)
10
Heater Target Temperature
10
System Pump Operation
10
Pump Exercising
11
Setpoint Operation
11
Dedicated Domestic Hot Water (DHW) Operation
11
Internal DHW Demand
11
Warm Weather Shut down (WWSD)
12
Reset Ratio
12
Heater Design (BOIL DSGN)
12
Heater Start (BOIL START)
12
Offset
13
Direct Drive Input Signal
13
Pump Operation
13
Boiler Outlet Maximum Temperature
14
Powered Input Connections
14
System Pump Contact
14
Installation
14
Heater Contacts
15
Alarm Contact
15
Heater Outlet Sensor (Field Install)
15
Troubleshooting
15
Sensor Resistance
16
Testing the Controller’s
16
Outputs
16
Connecting the Controller
16
Control Pin-Outs
17
Electrical Connections
17
Electrical Wiring / Troubleshooting
17
Factory-Mounted
18
Wiring Connections
18
Field Installation
19
Controller Settings
19
View Menu
20
Adjust Menu
21
Technical Data
35
Quick Start Set-Up & Programming Tips
35
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Raypak Temp-Tracker and is the answer not in the manual?
Ask a question
Raypak Temp-Tracker Specifications
General
Brand
Raypak
Model
Temp-Tracker
Category
Temperature Controller
Language
English
Need help?
General
To Previous Page