Steering rack and pinion assembly
Check the
clips
fitted
to the convoluted neoprene
seals
for
tightness.
Inspect
the convoluted neoprene
seals
for
damage,
fit
new
seals
if
necessary.
Torque converter transmission
Change the transmission
fluid.
Preventive Maintenance
Control linkages
Apply a
few
drops of engine
oil
to the
accelerator
linkage
and to the gear range
selector
controls
adjacent to the transmission
casing.
Electrical system
Check
all
interior
lamps,
exterior
lamps,
instruments, warning lamps and
devices
for correct
operation;
rectify
if
necessary.
Parking brake linkage
Lubricate
the
pivot
pins
and
pu
11
ey s in the parking
brake system
with
approved grease.
Spare
wheel
carrier
Lubricate
the spare wheel
carrier
lowering
bolt
and
mechanism.
Tyres
Check the tread depth of
all
tyres,
inspect
all
tyres
for
signs
of
damage. Check the tyre pressures when
they are
cold
and
adjust
if
necessary.
Note
Include the spare tyre.
Test
Road
test the car
for
satisfactory
performance.
43
500
miles (70 000 km.) or
31/,
years service
whichever
is
the earlier
Essential Maintenance
Engine
Change the engine oi I.
Fit
a new oi I
filter.
Battery
Check the I eve I
of
the e I
ectrol
yte
and
if
necessary
top'1..IP
with
distilled
water.
Belt tension
Check the tension of
all
driving
belts
and reset
if
necessary.
Brakes
Inspect the footbrake and parking brake
pad
linings,
fit
new
linings
if
necessary.
When
changing the
footbrake pads examine the
condition
of
the dust
excluders on the
calipers,
renew
if
necessary.
Manually
adjust
the parking brake pads.
Inspect
al
I brake pipes and connections; the
Dealer should report any
defects
to the Owner.
E25 • 8
Fluid
levels
Check
all
fluid
levels
and
correct as necessary.
Preventive Maintenance
Carburetters
Top'1..lp
the
oil
level in the
air
valve dampers.
Control linkages
Apply
a few drops of engine oi I to the
accelerator
Ii
nkage and to the gear range se I
ector
controls
adjacent to the transmission casing.
Electrical system
Check
c111
interior
lamps,
exterior
lamps,
instruments, warning lamps and devices
for
correct
operation;
rectify
if
necessary.
Parking brake linkage
Lubricate
the
pivot
pins
and
pulleys
in
the parking
brake system
with
approved grease.
Tyres
Check the tread depth
of
al I tyres,
inspect
al
I tyres
for
signs
of damage. Check the tyre pressures when
they are
cold
and
adjust
if
necessary.
Note
Include the spare tyre.
Test
Road
test
the car
for
satisfactory
performance.
SO
000
miles (80 000
km.)
or 4 years service
whichever is the earlier
Essential Maintenance
Air
injection
pump
Check the
belt
tension and reset
if
necessary.
Air injection system
Check the
air
injection
system for leaks and correct
operation; renew any
defective
items.
Air
silencer
Fit
a new
air
filter
element.
Automatic choke
Check the
air
flow
through the choke
stove
pipe and
check for correct operation;
rectify
if
necessary.
Carburetters
Clean the
air
valves.
Remove the
filter
cover
from
each carburetter fuel
filter
housing and
fit
a new
paper
filter
element.
Top'1..lp
the
oil
level
in
the
air
valve
dampers. Check the
float
chamber
depression and
rectify
if
necessary. Check the
idle
speed and
rectify
if
necessary. Check the choke
fast-idle
speed and
rectify
if
necessary.
Carburetter mixture weakening device
Fit
a new
air
filter
element.
Crankcase emission
control
system
Remove and
clean
the gauze flame traps
in
the
crankcase breather tube. Clean the adapter in the
choke
butterfly
housing.
To Next Page
Loading...
